Report (102) MIMIlastatitie
Ziff:AL IRON RI DGE liE ,j _,-i Flash Foot TM
AUG 2 2 2,(Ji( I �-7)r 5w Ct</6e/if 47
Rapid & Secure So!a.r Atte chn en is �� .1§.igti-i
tiTYOFi GAD . �
IronRidge FlashFootTM is an all-in-one solar mounti r rG- �� ' `�
::jirw 700,,,o,;!::..sililoy...,.s..:::„.„,..
product for composition shingle roofs that eliminates the .1a,
need for separate standoffs, flashings, and L-feet. I 4 f s a -
14 z <_Iv«:,:}S: a ..i :"..'''''""'l4.2'''''''''''
r ,7 3•..' ,.3 p,
FlashFoot incorporates a number of structural and ..9- ji `ia.>r»°==: ?.'ii,:?:?.44:
waterproofing features to securely attach IronRidge x tr .'i :;>?»,
Rails to roof structures, while also protecting against �:::::
water intrusion and weather damage.
' Dual Mechanical Seal
',:i:•:.;:•;,..,,,„
At the core of the FlashFoot,a pre-installed
rubber bushing forms a dual mechanical
seal,with its exterior compressed against
the cavity of the L-foot and its interior tightly
�e wrapping around the shaft of the lag bolt.
G •o 1
4 • • •
'
•
...:. -.. -'- �tiY•y�PF°.:^i��•�::.:.::. �
•
•
•
•
•
•
a.
•
f
ttay�,,,, }:
Load Distribution Plate
A solid metal plate below the L-foot
increases the FlashFoot's structural
strength and prevents any deformation
of the flashing during installation.
Water Shedding Design
A wide flashing layer combined with an
�p Certified compliant elevated sealing platform maximizes the
P^^o with IBC and IRC. FlashFoot's water shedding ability.
ES
Installation Overview
Tools Required: tape measure, chalk line, stud finder, roofing bar, caulking gun with an approved sealant, drill
with 1/4" bit and 1/2" socket.
t
r i i
3rd course
.
4 Rafter
2nd course
{ )
gg 1st course
Locate rafters and snap vertical and horizontal lines Slide flashing, between 1st and 2nd course, so the
to mark locations of flashings. Drill 1/4" pilot holes, top is at least 3/4" above the edge of the 3rd course
then backfill with an approved sealant. and the bottom is above the edge of the 1st course.
_•a:lmar.:.: a;'r`• '.....ra);•m ,. i '3
;v xc _
{ i
aid T PAPP.,s' 3ER — S r _ 3 :.'-•,'f tr- 11114.T
s Ix
.i E lia4
Line up pilot hole with flashing hole and insert lag The FlashFoot is now installed and ready for
bolt through bonded washer, L-Foot, and flashing. IronRidge Rails. With provided L-foot fasteners pre-
Tighten lag bolt until fully seated. loaded into rails, drop rails into open L-foot slots.
Testing & Certification
FlashFoot is certified for compliance with the International Building Codes (IBC) & International Residential
Codes (IRC) by IAPMO-ES. Mechanical testing conformed to the standard for Testing and Analysis of Joist
Hangers and Miscellaneous Connectors (EC002-2011), and rain testing conformed to the Underwriters
Laboratory Standard for Gas Vents (UL 441-96 Section 25).
E... .e ..a: .:.A.S: � '• ...i : � .,. :�5>• ..«..yam.
Douglas Fir,Larch .50 t 798 Y
Douglas Fir,South .46 705
Ii Engelmann Spruce,Lodgepole Pine(MSR 1650 f&higher) 46705
Hem,Fir .43 i 636 I.
i Hem,Fir(North) .46 I 705
Southern Pine .55 921
I Spruce,Pine,Fir i .42 615
Spruce,Pine,Fir(E of 2 million psi and higher grades of MSR and MEL) 1 .50 798 i
___ _ ,._.,......__. ..,.,..., ...---- _,.,.,,.,,,.�- __ ._....._.,..,,_. ,_,,,,....m..,..__
Sources'.American Wood Council.NDS 2005 Table 11.2A,11.3.2A,Notes.i)Thread must be embedded in a rafter or other structural roof member.a)Seeee IBC
IBC ifor required edged stances.
MaNistNittatit
414-4/ IRON RI DGE Roof Mount System
w
,fix" Y' 74
:' . .r=te' "
I ( 3
��,' § 3 E
_.;,44001514,1f4'
:s€h§;i xE ii` Ef.3i;1 : ;�.._._._ 141,11 w:£-•_�" Eas`;-?
....... .^..._ :-,� 3 s� �.��?`f i RjcisE?P:::i!^i�tE?'5:....:'.�r�?.::� :Lid' ,^x r:u..
..........:::....... �
..illi•••........^.... 3 � ::2.:::£::i:iiiiiiVic"iifii§ii.J<:"f .;:,nt'.
......................... f rt a 3 rrx: .:.•"G- :::I c'..I3.4^3;i a-Y: r• u::-:::
.... - -..� ..... _....^......._...._.:r.:.:E.•r.....:3 3 rE:33`.:•v;;r.E.•;'.•c-::iii :;::..
y.a£,. .: 7•F.^.:....^ ..r..._,_✓' •- £'':£33 if..' f ars,
.: :iii:€::::.yp T'"R .�.u;;.. Ski€_i'a".-:Ea:v ::em.;::i:•�c''�ii•i 3
:€ :i£ii>r::zai�i�FE,EY�i£, x... '- f. 3 '§ ( . 'S'
Imiliiiiiialliallit
..............................................r::r•:s^_........:p;.�_.ss;'
.............. v:asacNEaar.Fc.:•:@..;^:_.::^:: '
.a.,, .o...:::::: zr: > :::
pliEst^
..:: amed.....^...»:... ,em..p 4 s, : l
Yxligli•
.: . .'.:.:. :i:i:: :.. ..:i iii
Built for eolar 's toughest roofs.
IronRidge builds the strongest roof mounting system in solar. Every component has been tested to the limit
and proven in extreme environments.
Our rigorous approach has led to unique structural features, such as curved rails and reinforced flashings, and
is also why our products are fully certified, code compliant and backed by a 20-year warranty.
Y Strength Tested PE Certified
All components evaluated for superior Pre-stamped engineering letters
'.'1, ! :,::: :::::,::7,i;! : :,.' structural performance. _ available in most states.
Class A Fire Rating Design Software
6
,I.„,,,,,,,,
::,.,,„,,,,:,,, ,:::„:„:, Certified to maintain the fire resistance Online tool generates a complete bill of
,.. ., rating of the existing roof. 4 materials in minutes.
Integrated Grounding ?)I 20 Year Warranty i!:!:0.:,',i'!;..
UL 2703 system eliminates separate Twice the protection offered by
module grounding components. competitors.
_�,.., XR R cit k —...... ._._ -0,.. -` ,0
XR10 Rail XR100 Rail XR1000 Rail Internal Splices
.
t ,: 41l
A low-profile mounting rail The ultimate residential A heavyweight mounting All rails use internal splices
for regions with light snow. solar mounting rail. rail for commercial projects. for seamless connections.
• 6'spanning capability • 8'spanning capability • 12'spanning capability • Self-tapping screws
• Moderate load capability • Heavy load capability • Extreme load capability • Varying versions for rails
• Clear& black anod. finish • Clear& black anod. finish • Clear anodized finish • Grounding Straps offered
—_,.,a. Attachments _ _.. ,._. _� _... x_. n,. mM, .__ _...__. c,,._,x _._..-.._
FlashFoot Slotted L-Feet Standoffs Tilt Legs
,ir
I R. r
r:,..i l
.„.,
._,
.i.
ris.
_ _
iit.;
a
liftia:',44ae, .i, i
,:,..,,,, 0, ,,,,...... ........_
a,
Anchor, flash, and mount Drop-in design for rapid rail Raise flush or tiltedTilt assembly to desired
with all-in-one attachments. attachment. systems to various heights. angle, up to 45 degrees.
• Ships with all hardware • High-friction serrated face • Works with vent flashing • Attaches directly to rail
• IBC & IRC compliant • Heavy-duty profile shape • Ships pre-assembled • Ships with all hardware
• Certified with XR Rails • Clear& black anod. finish • 4"and 7" Lengths • Fixed and adjustable
End Clamps Grounding Mid Clamps C.:-.:, T Bolt Grounding Lugs E"4"< Accessories
4,A11, tot .:
"A ,
light
:!;MiiiliiiiiiiiiRlin 2-jr
int
Slide in clamps and secure Attach and ground modules Ground system using the Provide a finished and
modules at ends of rails. in the middle of the rail. rail's top slot. organized look for rails.
• Mill finish & black anod. • Parallel bonding T-bolt • Easy top-slot mounting • Snap-in Wire Clips
• Sizes from 1.22"to 2.3" • Reusable up to 10 times • Eliminates pre-drilling • Perfected End Caps
• Optional Under Clamps • Mill & black stainless • Swivels in any direction • UV-protected polymer
---- Fre,: Resources . x„,
-v. Design AssistantNABCEP Certified Training
Go from rough layout to fully Earn free continuing education credits,
engineered system. For free. 4 AL while learning more about our systems.
.- ,,.. Go 4 Rid€ ..:r 4 e to Irco4;;-,,cocol 'k:ig
gv,
wombats
lir:A. IRONRIDGE XR Rail Family
Soar Is Not Aiways Sunny
Over their lifetime, solar panels experience countless .�� /
x
extreme weather events. Not just the worst storms in years, / •• �� , �/ ,, ,Z1' t, �
but the worst storms in 40 years. High winds capable of , r' .� a `~+;
ripping panels from a roof, and snowfalls weighing 1 f r
enough to buckle a panel frame. j` * j• Z + P
ti{ x i i
XR Rails are the structural backbone preventing ...,i,,''. . - ''' ''''''''1. i ' 't '
these results. They resist uplift, protect
against buckling and safely and efficiently `. --_, • ---, ''',,,,. - - _./ t
�-1,y,
transfer loads into the building structure. . ,, g E --- .
Their superior spanning capability
E � - � v
requires fewer roof attachments, ;; '
reducing the number of roof `
......:..::::::.:::i.
penetrations and the amount -• *'.,.q.::•;,:,,•:2::-.--,..:-"•':-.----:-.-<1..2.- --7-1-•::-‹�..F ... ' `-=T'n_''ii ....tw-L.,F#„ •t�y, . :--.
of installation time. Fet 't.- ,_
................. ...::
..::...........
............:
.....:::.:.:.:::
•Si�iYry-�': 't'
1[10.
t '
E
Force-Stabilizing Curve
t
he Sloped roofs generate both vertical and lateral "'
w = forces on mounting rails which can cause them
.,. 3 to bend and twist.The curved shape of XR Rails
; . qk l is specially designed to increase strength in both
r ='- " E ' � directions while resisting the twisting.This unique
� E,
s feature ensures greater security during extreme
i, weather and a longer system lifetime.
sr-----'''''4 -' ''
' '''''''''''''"'"'''''""
Compatible with Flat& Pitched Roofs Corrosion-Resistant Materials
XR Rails are IronRidge offers All XR Rails are made of marine-grade :i.E
compatible with a range of tilt leg i aluminum alloy,then protected with an
FlashFoot and options for flat anodized finish.Anodizing prevents surface ,
•
a
other pitched roof roof mounting and structural corrosion,while also providing
. attachments. ','.,'..-:',...,::::-'1•,..,,,.,I applications. a more attractive appearance.
matii-kiittow
XR Rail Family
The XR Rail Family offers the strength of a curved rail in three targeted sizes. Each size supports specific
design loads, while minimizing material costs. Depending on your location, there is an XR Rail to match.
•• ...:vt:ij l.ii2:a„i5EiC..
............. € ......................xma':.-"iii�iiii;
•
•
•
"moi +Y....•' . ; "' .....-y,
wu� • ywWiwry • w.
XR10 XR100 I XR1000
•
•
XR10 is a sleek,low-profile mounting XR100 is the ultimate residential XR1000 is a heavyweight among
rail,designed for regions with light or mounting rail. It supports a range of solar mounting rails. It's built to handle
no snow. It achieves 6 foot spans,while i wind and snow conditions,while also extreme climates and spans 12 feet or
remaining light and economical. maximizing spans up to 8 feet. more for commercial applications.
• 6'spanning capability • 8'spanning capability • 12'spanning capability
• Moderate load capability • Heavy load capability • Extreme load capability
• Clear&black anodized finish • Clear&black anodized finish I • Clear anodized finish
• Internal splices available I • Internal splices available • Internal splices available
`i
Rail Selection
The following table was prepared in compliance with applicable engineering codes and standards. Values are
based on the following criteria:ASCE 7-10, Roof Zone 1, Exposure B, Roof Slope of 7 to 27 degrees and Mean
Building Height of 30 ft. Visit IronRidge.com for detailed span tables and certifications.
i;:... :.::..,...
........::..:.::
»r;; Wrss} ^:zs:i :8:H::t :^^:i3vn:i"s iyssir.
-::°c '
• 100 _ _.. ......................... :. u-Fgaxti.AiicEr. . i;
iii:ii:i:y.iS;...iiiiii.::.::.E: -:::v ,6:}}}?zi1351gltgiiiiisrkk? mE
:.:.::ii.C..,:..:::::.:.:..:,:::4::::..:::.: r....r,Pm-E!?TLv_ ii! :~i ::E'EE»?}itiic}i^ER•
120 .................tligi�: IT?T^_::rro.iiig:Et;:4ei:=»{:?::?::c?::ssr,E.:.i:::_ic:::aai.
None
..:......a..:..:..
140 XR10 ii�:�::.< �.�.:....l...:...:.....�....x...;..,'..:..:..::...>.'...:`..:i...:..:i:....E.:m.?
..;..,.: :.�.-i}:.....
at„.....»,?...;E:
�.^
.»^r:d:
roiix^wim°<:m�c
Wa:�wvm
_r
E.-:.
M,_.E;..'.2......a..}....-R....>.-.»D^.....=»-.,
:
` i :
�: sr� ilis �i� �ceM1
160 .:.......:.t:is-:.' ......... .........:::�....i..:.:..............';.....;..:.:..::.:.r.:iiCl::»:-bilv}m' c3,}r...m' }ii}^ii?5 "ivFiu' `
1.
t_._"_ _ "--- : ;..i ............S•.......:. . ?::.:.:: i.:;::.�.;.. :_...-.....sr.c,.».:::s"r.�E :etn,::a:.-:::i-:x:: :»_F.::?i..-..:.100 t <.::..:::.. .::::::.:......... iiiat::ii............:........ .i::i..L-:<.. :... :rE'»»,,:�rr,;.k,srsr:sr:.ir,..1^:Ti »R} rE
-
............:::............ ....�i'S-.:`:E:SE'b...:-E3 } =..;;;::;�::""";......��<E5sEY_.c1,:Sr?i;
1 0-20
................ ............:::: ........ r.;
r.:::::::: ...................................fc;rE2;}}z;s'miiiiiL zE:et
140
160
E
E g
100 ........... ......................... .....!!!!!.;1!...
.: ::::::.:..::.:.:•.:.::
✓a a Sheet
Enphase Microinverters
The high-powered smart grid-ready
Enphase Enphase IQ 6 MicroTM and Enphase IQ 6+ Micro'M
1 I Q 6+ dramatically simplify the installation process while
1 achieving the highest efficiency for module-level
Microinverters power electronics.
Part of the Enphase IQ System,the IQ 6 and IQ
6+ Micro integrate seamlessly with the Enphase
IQ EnvoyTM, Enphase Q AggregatorTM, Enphase IQ
BatteryTM, and the Enphase EnlightenTM monitoring
and analysis software.
The IQ 6 and IQ 6+ Micro extend the reliability
standards set forth by previous generations and
undergo over a million hours of power-on testing.
Enabling Enphase to provide an industry-leading
warranty of up to 25 years.
Easy to Install
• Lightweight and simple
• Faster installation with improved roved two-wire p
r' cabling
• Built-in rapid shutdown compliant(NEC 2014)
E1
Productive and Reliable
1i= • Optimized for high powered 60-cell and 72-
.
2-
cell*modules
• More than a million hours of testing
'<efi gip..,mrr3'�i3Y:E
• Class II double-insulated enclosure
Smart Grid Ready
• Complies with fixed power factor,voltage and
frequency ride-through requirements
• Remotely updates to respond to changing
grid requirements
• Configurable for varying grid profiles
41)
• *The Qu
6+Micro is required to support 72 cell modules
CERTIFIED
SAFtry us ca
E341165
E N P H AS E..
To learn more about Enphase offerings,visit enphase.com
Enphase IQ 6 and IQ 6+ Microinverters
INPUT DATA(DC) IQ6-60-2-US AND 1Q6-60-5-US IQ6PLUS-72-2-US AND IQ6PLUS-72-5-US
Commonly used module pairings' 195 W-330 W+ 235 W-400 W+
Module compatibility 60-cell PV modules only 60-cell and 72-cell PV modules
Maximum input DC voltage 48 V 62 V
Peak power tracking voltage 27 V-37 V 27 V-45 V
Operating range 16 V-48 V 16 V-62 V
Min/Max start voltage 22 V/48 V 22 V/62 V
Max DC short circuit current(module lsc) 15 A 15 A
Overvoltage class DC port II II
DC port backfeed under single fault 0 A 0 A
PV array configuration 1 x 1 ungrounded array;No additional DC side protection required;
AC side protection requires max 20A per branch circuit
OUTPUT DATA(AC) IQ6-60-2-US AND 1Q6-60-5-US IQ6PLUS-72-2-US AND IQ6PLUS-72-5-US
Peak output power 240 VA 290 VA
Maximum continuous output power 230 VA 280 VA
Nominal voltage/range2 240 V/211-264 V 208 V(16)/183-229 V 240 V/211-264 V 208 V(10)/183-229 V
Nominal output current 0.96 A 1.11 A 1.17 A 1.35 A
Nominal frequency 60 Hz 60 Hz
Extended frequency range 47-68 Hz 47-68 Hz
Power factor at rated power 1.0 1.0
Maximum units per 20 A branch circuit 16(240 VAC) 13(240 VAC)
14(single-phase 208 VAC) 11 (single-phase 208 VAC)
Overvoltage class AC port III Ill
AC port backfeed under single fault 0 A 0 A
Power factor(adjustable) 0.7 leading...0.7 lagging 0.7 leading...0.7 lagging
EFFICIENCY @240 V @208 V(10) @240 V @208 V(10)
CEC weighted efficiency 97.0% 96.5% 97.0% 96.5%
MECHANICAL DATA
Ambient temperature range -40°C to+65°C
Relative humidity range 4%to 100%(condensing)
Connector type MC4 or Amphenol H4 UTX
Dimensions(WxHxD) 219 mm x 191 mm x 37.9 mm(without bracket)
Weight 1.5 kg(3.3 lbs)
Cooling Natural convection-No fans
Approved for wet locations Yes
Pollution degree PD3
Environmental category/UV exposure rating Outdoor NEMA 250,type 6(1P67)
FEATURES
Communication Power line
Monitoring Enlighten Manager and MyEnlighten monitoring options
Compatible with Enphase IQ Envoy
Compliance UL 62109-1,UL1741/1EEE1547,FCC Part 15 Class B, ICES-0003 Class B,
CAN/CSA-C22.2 NO.107.1-01'
This product is UL Listed as PV Rapid Shut Down Equipment and conforms with NEC-2014 and
NEC-2017 section 690.12 and C22.1-2015 Rule 64-218 Rapid Shutdown of PV Systems,for AC
and DC conductors,when installed according manufacturer's instructions.
1.No enforced DC/AC ratio.See the compatibility calculator at enphase.com/en-us/support/module-compatibility.
2.Nominal voltage range can be extended beyond nominal if required by the utility.
To learn more about Enphase offerings,visit enphase.com
2217 Enphase Energy_All rlahts reserved AI!trademarks a, brands,sec are the property of Enphase Ene,gInc- EN
PHASE
f'1 G C A f P lJ A S E
2017-05-01
:::"✓"alta. : '; a:
v 05.._... _._.
.,._...a....a P.a.. 'F ...c...» �'L.«» SI.''''';'1,-i'..:u.,.....,:¢. ar.,.«.x••.. .__ . .o..«...•»....»..•.....xc°;��,n<:c'�?i.✓:.:;6:T:.•' �:.fr3�.i;- =«:Ej..F
,.,..a. .,u:r r<^?•.�: _sss.-.r,..v...._..._ ,..»_ .:...... .... ..... ...x... ..... _n.........x ......._nc.... _.€•�?er_4i o«:.`' ei<�k'»r
,._..:..». E. . ^s._»ar.,._....v..:,..... ,...^,vin ;_..- ;`;:."''•�:
3"iv='=St- ,vc........j, _.._.... .:; .^.. -_._..... .:r•. ....aft.•e3a9��:...z� _...a.r,^..•v._.._.a..._... ..._.._..._•F _. .. _...ar:.�;.x 3^:::'av::ys�Ln:;i�i�
:zi a,z,.,.,, _,:;:a,,.,,,,,,..6v, z_, o._.,.vi a, d:_,,,,.,.n,zir•:,,,,,.,,.._..azr.•••;;;,,,.,_.a^n...,.,_„ ^,v3 ali4t a ,vh,,_ 19?41"t:r.,: :z-;�Y 3-••:;`:.-(T
_,,�+":::,�. ..^_.�,. v::`fr• .:: .. ..rf•�s::».:::f,...:iz`.<..":v... .....xf ^?;::q...... ..-.._..... .-r;: 5=:::nv............IF._,. zx^vz.u.....i�.°•f vCmS:.. ..3, _...3z.^z... .:l:h::: �:�fdLac:::?:h.
3':;:,:;.e?;._'1=...�:n:-..:�;:->?:3:n:._:�.3..._, .. d-_._....�•:-z�"::�._-�._•,__......3�.rn '� ,;�::-:::_ ''___ �.... _.__... .._:nn_r. : :<'� .5�,a' a::.>£..:: .r_::3.-�•n .9_ ....5
.,.+.v;?3:::ra..•::....,...n.E..xv..,:. .v-z.�.f, ...... e v,...^..•&.e.._.3Lr'_.vzr._a__: .........._YzS:�E3S.,.."..v.v.<:�;....R .",._::a::a,3=u:an.•eiece3i'R.•rr:tt r::':: ._...,.:-'• .fv�,=n:3 "..„�vs.^,v, �e!Ea•::3?i,3=<:::::
-,...M.::....__..... .,..._.._ ••��. ... .,.. .. .r:3.-::m.,, _,..,...>.;,;;;__.. __.._ ..�3.:r:::�._,.... ....3 b�::.,._.. :� _i?ms ::3.•i•:.•:�.-:::?!:�: _
r;,.,:aa�,:,.,,n:,,:a:. .,a:.:Ei.a.6x. ,,,,_.rid.... .? -s^hi:A v,:fL.•T ,.,,,,,, a:u-.",.a .0... "n....,li apR;.zv--i::g:a:::%-:_ f. m, a •i:?i�a= ,_.R ^ SFi•lams:::$•?.
s—_.>.,-._. ...� .,.__ .._far,..._ ..� �3a•.:.;.;......3,n�Ms .. ..,_. ._.a. ..:.,:d�.s•, ._".da.r-:....:..,_ ..r:,:::a:......•.,_a.� ..::,a...�•:3i�,�._••'=��r... d:Fa3:•::aSkE::
:r '' •a::: ,zP:-ws._a., a-,. ,, ,a,. : ,,,. •: .,._,,,. .. J:„^.. ,^n�'r,:::n_ a .,»._. ,:,... -,-:c r;.T;..g;.,n.....,....>:a.-a..n:._5•:•,_y:r;r=:fc•; -,:?f: ,..,,:;rva::•::,F
?An'rrv3E :'z':: -. :ua: _:_.f.,.,.........„....=.0m,„1„00.7—i,„...,„-.4,,..44,71€•c�, , .a;ar....":fS..__.,. .._. .. ^:„ ..,.E....:- .,r _.:€- ..,i'�_». - _...3-z? •u:Era:yk s ''.-:,r.<`if;.>?tEi''
...»d...-.s.~�fa::r z. ..f.. ........,. F ..."",z:r ........, ...z.9 7 � j;, v:ld..a... ^a ... _
....... ._ , .'tt_z:h........x.. ..SP'v:.: "^.».0::.:h ,..._..... .:a:,v,Rz.�3,z.;;u::S;n,;: .;...:..a a::d:e E�::cii' ;.zF1,zF7.:.:Y:e•:- �-.:
.......a,.,...a.:::..._.>�.:._..,n a....... ... . ..._ ._ .a- r,. �,.__.._fi.E r:._.. �_-..3,....._.3� 3_. :.`;�-=:._ m�... -7.^�!I'f:<.3-.:,r a�._L:.W.'' ., �i'o:€;:
"3•:a „.f E_. ,•'�.:;=z-: .,:�.--,. >.,::: _,_ u.,lc)
l•= :• a.•::x,7 .-,_,a_.._ .,,:,, _. r ?., , ,.-....3� -`r f -
:.:.:.-,:,:..._ e € .:...,.. .ra•3s3 a. .;:, ... :»• ,r. ., _. ....::._...... .-. E�_�'F,�::::n,.r--..a�^ala 3”n=�::'.��;;3 P .:a:�.�:_:�»::;;;:s->:r _;..3E:;.,;s;;<
..,,..i::r._.. .ix:�f::F;....,a4'L. •-...._.,.. SE aa, .;;;..,.. ..-: : :a ar P<ri,:,v_€ff•r.... ....... .�'c•v ,xaa;�P:::rvr s!ks, E:_a•fi r?,<-^.•,5z�„E-33r?F3:5f'r.n,;;,,
a:a,r..s.a•r<� : ._-•, . _. :..�.n. �. _.... .. ',3.... � :r 3n. �...r.,.::...,_.� a3:s- - -,°`a35:ri•.:. ...�._. i�.�-_ ;2
_.1,. . ,.. s3; ,,n,,. a;; _3137". ,,.._ .r:- •• •i a:ate i,:••::d frgfig =f gift >f f ., :a"�:siiii:'u;;=•:n e : 'iej:-::
.::_:��:n• ::»•.: ... -_.._ .. F,,, ..`.� »:3 ,,4�' _ 9.>..a.•r.... r ar.:.a r:n••.::q:.� �':�';:sz:.:.,-:'x .�':::ff:�:n: �?,I-y�s4:3:,,;;;,,F.PE>w;�
-5_�3r,.3�...... a .F:° � .. ? . ,...P. a3 ::-•:::~�-4r�e:a>::::i�.-: ,3 , =:�� .. 3ffi:;�:_`•�<:.,�,_.:...__. ,r �s,:'.iP._„
�: .. x E -} Ym .. va• ,...-Es.-u.i:v.._..... �.:....€:n:zcYy:h'v..-,FE:ir?is a:a��•�' ':.: =:sSv.;..:...s.",.:::-?;a:r?..m. 'f':.�E�: L:?#.,:n
;:�:f E:,E; ;:?,:i:: ,:. :, s , o ,r t F d:r •.,,.t _..:'?;-.a:::3,# u ._.tnig ..�:�r - !"p;r_. .
_�, _,.T.�;:e-Wim`_ ., ..r.. ��-:fi=N
•dr ..:i... # :.W.:ar> . �.t}' • ,.a �fE33._.. h3::=€:::: >•..aia,ai € .3,.. .,s:z•:r - EE'3a'f^:i3334. �`=:# x £ 3t' .a:';'�`E,,;.:..
y
._:,".-_.., sir,.:.-. . � ...:,
agg41§:: •.p 3 :3F rv.` 3', Wit. ..ziy_ i- .: ���3.",iv;(;,...v .,,,3i34__r a:zi[-: ,:dF:E.rtz: tii4,,._:« ,:::,a.. -.F:: c:V f?f.- .. . :ES' ,.......,..7.' va. . d ..•c �. d€x : ., £ ...-c:.... . .,, .. ..:."-r......4.?i,3.�S tt?ifii�ef}!`' �y3`3}':�:�� 7:::&:-�a.3e:.r ._ :.m,w... RE?€.�v..ii,,,r uE s. _ ,. m;?_ _... ..,,��. ... ......._ . . ...._. ". ...,.�.rzv ..� „ .ss..a a::. _ ....4iEi^3qi fii:l (W � � -s'Pi�s._.. ._ ...€?.";,v>�,3:'_, ...., ir.. ;.._:tnv....-...,...FTh.;.u•. .. ...^g..0::$3,,y....... •3r.3:333v....... _:n'".•_•a:. ..3 ... �i,9',�>�i:ur..•a,,::;-zl e::s3 „ -E:ri-::vFJ : .,a:. ^^ ,° d3,: ,:. "a,,f Jd ::.i rn� 914-'1 e„Ty " 1.111 6'!'=fRf, ,:i3"
.�3i•_•ac a:�me,'n,�,,a.....�:..P....^s.:..��,:3".a,,,.._;.;.:. _. :- .;.,_e... �-.; n..._�. ;:�.::�i•':�x!ssi E':°-?�`. •PE?.':i=:;ii:}r8:•:. •� ?�??�-' ,�mu:.a, :- v.3x �;;�i;:r�:�.
.. ..g,F--..,-..,:-sa,...,•a.:rte,:n: ,... a,,• ;, ,,,..: .3 '_•., • , "baa..,. €E - °1;,,_ �,kii .r:: r _ �::i{EI:_,. rrs="�:ii: :r•;
an_.. ..,.:" ., _.,,..... 4,•••-= •a: _..... ..w ...d::^, - "=-m;<i'::•�->3s '"�>. Pa.eaf. ,.:;�, �?_ EE4::i,•-:>
._ ...... _.__ ,.,..,,t, .__.a u<:�u,,3s::•v:::.:..........;i;i.,i::c�::° z�?I. .:lls'�,«st�:.. .E<% ...»,..i�-• d -" r•
:>n?:,T.W«'•a"x.E,-?p,. E. . : Tiatir: _, r -• .:,:.rfs,7, r::aa«-:::fig ,vir:.• -•-B3• ^ :,_` .fit is%`'i«`:a:.,
a_,_;.d.-.. .,.... rt.,., � '. ...:,.;;.r.....4! .. # - :::::,,::-.vd>n_sdd:n.:;-:�:::::•::�:?:::::a33^:-••.f.... ,3?iN;:�3:?r-:?< �:' ;mak•.Sit::��:::;,�""�i;•a ==a=:"v;: ���,.<.<ro
:as:?r..c'„•••>f„E a. ,F., ;.. 3::: ° e.' s::.: x ° 3 ..�.._.;3s:e?�_ .._ � ,:k: i y� app:•:: veE......:f.,�: "<33Sfvrfz°'•n...,'':
?pp�� ,-:. _,x3"'e:::iEi-fi��:iFzi;;?z'''iFfi'i?irs:Y�3-'':::P. 'a In'i
g - : »:, a, x F g .. E. : :•c=e:'rii„c_E?iY•s• :.
• :: .:.. .. ax :L•. .. - rte. _. •- :, P r. ....:3^-;;v;:::i:.f:'F-:: o�:'fifl:zMi::......_?iHrr:ny�,',":=^,3,.3P'eE:_;•�,-,_'a";�pf-:,en�R:-� E �3r � ,.I.3.,. .:..rbz:
3� �u._::. ,:c'•s�::.'4i:-:�,:�fam�,,c. ..; ...': ....,,-..:;.-::. ��q�;••aa3??Ev i"'::r<�::r.. �sy3S;e?uS: •::::tS.'fii F.n ; z,T„ �'�� : - (zi� �a,3.";,
49474,11,-iii.': ,:J,9... ,.._. „m,_. o,,._:33 -,S:fg3:_,�.:_.f?iE!S'r:,:• Fs:-�:EE,,:•••441iO3z 93 :::i,,,,«vzs„c •-: 514 .A; ,'7 'Ar : ^•>=a ,....&':.. dF-max... . :Fr•: •xrd•1
� .'fr .._.. ....;,t?:.w.;�ti;�.... ......n..-.�=.3,,.3i'�, '.�._ :::: 11_•:7x• ,ss>i;� _.. r 3 :.,,s�.d �_:Taira •, _ -�' ,.�•,,_ ... ir
,.4 _a,.3 ,.a,xr, .:,. i a-a:,i is3::e iii .a,,.,,,.,=n.9, •3,x,4;,011',''-ndn•,., ,.,_.f' raa 3�_.. is
d_i:1`•E,. •:._.,_ .,...9si:.._..,u_:,. :ii-.•••,_.a::_.;:,-s..._ ' i:;,4i.;: ��i:. ;,� '' ::i;i'f...,
.- ;....r«: :a;ga.}Ifi::v.,:F. ::�E�5..�:a53.u;:•::ry ....9's ...:::, ......5......., �{ :........__ ....:R...._ ...3,3.. ., ,,zzyy [ zr=m�.••13 d__f.....
:,:a ....,n F- -�+zz .^.: ^..°.. L _a........ ........z. ... '^:::R.�u..._€. s.,v9'":441.011* -ir=E,
:r. e£:v:. .d,96.2iii,t.:..r J.....,v-,,,.3a_ v31>I ,lift,3'•.pi€i ,,, ..;,;r-iffi:u_ ,^. ,...., .,, „c.:tt_,re4i- ,_ ^•3�=-'_ .,z f „-, ,_33..
....:^:.., ..... a.._. .:,a.>.r".dfi z ..... ... ^.... .v.,3 z..z z.,, rn.., u_.�3f. z. .:fRi...:,v,J,.*_....... ...:, _ ,'^.'.-«�-,��'-''.'• ::r-: .':..vE. .w:-.�.�..,: ..3.
,_
�v .iCa..z..._..:E-::.m...z-7n.'»..•:v �3.....,-�M. ;af:z. ..._.... :n: .€.....z,rz ..^ }-,rfa 9P,.;v,O.L�t...a,.:......:�°..i:.''v=5i: •..;{:dii4:�3:::v''i%iii::._�.:.. .;;;,P:.i:r&...:.::
..•:,, ..; ;,y�ii=:::W:2SEi-c�i3 .•.".. ..-.., z.... z_•'ij,';"' €�_.^r'+ -.. °€:..-•-�'?it•- ':Els. .;..��..._.._ _'E v-f3ii??i;., ...5.3 .,.[r.^ .!':• .E.
.;;.._�'z,-;.3. •a:-:::,:::.-....., rv�..._.., f:€;..i cu .... Via;, a: :.....:a.z._:iL YS:3.;:m..._' ,•::.,' :€r.. ....� •-:: kit: •^:;3�•::_.._ :6::nf cax.'.;W.{z 'x.e: vzEa.,i__ aa,R
- v _..., itil , ,v,�i•.€..-,..9.,. , _. ._,.: r, .._` .,..r.�o ,..,,_,,,,,g-Ni:: ,3e:;...34piiibii':,,ig,.,W., iia^m:,;a:-, 41'" :- ^
a.-:a .,, Rv:� .". .-, .-_, c:z 9s...v... 6a:f.. � cn3rn.._..........__..>n�3......n:.., .iF ,-.•:..n.v,....._.3..-.:� .. .. .....��•f%'n "� ::rmr G�:^'3:3 ^'i.t x.:z,
,._._.. .._ _. �..a. ,. ., _,-�Wig....:...;,_3.._. r•• P--.:n.,_.n_Er ...._, _.__. .,_ ._�3:-. z........::•::::.:• 3"B E J.-... •iy:":.a�, Tri e, ,n;3,.�--Tr-1-i'
4�f ":a:�i
a, .. .... to _. ..:_�.. i _ ... Yf_. r t_._.n-,:::ii:
u._,. ...:,._.rnzr,.....ss .....3.:.. ...... ad ria...rf.......-:"" a':d.•z�n �•cr.,�-�"�f
...z h:•:rr.,m.:'f�.-„�”-.. G 3....� s..... ..:R.F "'.. 'f .,y��f"rr.�• r.:f n;.;_. ... .ci?c'c�,3xm•v ._._. :: :':••H.=.a=i v :5c`'4�x,�:�,z.. ^'�:-r'�r�g,:ti::3„z. ".-�.
»..,,,,, ..S7, nz..., .E,.,,,,,,�?•i.,,.,,,,•,.^p .,,F,K.,—••. an•i:: „_„ f,...•3:,:.: • ,}LTi- _ ,'L,,s..._,.r.'•
iv-..ib:4:: .vf..az. -a:•a z...n "^::c.,., .,..3 :"r+3 ,, .....:,,,^i7,a.F', v'i...:4- ....... ....c z.a.z^ n''s"_ a � S': - °„�'.z_..,i... jra>i;�ze: ^,'3Z'.4,,,
...uyaaii,^ .:._ �._;J,.:E »....v.a3`:� ..._. ,...v a�c: r....3a........zz:c:m..:r.... ;_..v .".. ....s_s..... •,da�' "frx......v�mar�3'•':: ,II...,.
:e. "_... ...-r n _ ^ 9,r..... _:aryl:._^- z., v... ....�::<;_... ._....._.. ;ar .�;,,.�,Tz...��,.. .:., vffiu.. .._.__ ,i:.;€:.v^:f:�9�isv� co:y.3.i•'r�"=•.r. ':2 'i�'^;�
:.'.� i3t.vh3ri��ldi.n�•- 3 ,.,.. .,�', � t,,,;i':a'€ � � f'N.� ..3.f'n ;x .-•.,>^q.., .:u. o..- .., ..p!..:..i . ... t��u: t33$i;..._..
x
l
} ar�
...... .:..
i}f�E •
S
•3 1 i
.
E
:?i:• . ,yam
3 a:..... .; ' 335
Tri .... ...............
PF .. ..... .........
-
•
v:::: r
0.1::6:iii:::iiii::i:i
.. . F I
! iii' z -
st
•
' k z, ? - - i
t,ifE 3
•
k .. a
- .2 1 F I
r ((( :
.. b 4 1,
QUALITY BY SOLARWORLD
SolarWorld's foundation is built on more than 40 years of ongoing innovation,continuous optimization and technology expertise.All production
steps from silicon to module are established at our production sites ensuring the highest possible quality for our customers.Our modules come in
a variety of different sizes and power,making them suitable for all global applications—from residential solar systems to large-scale power plants.
Extremely tough and stable,despite its light weight—able .:.: Patented corner design with integrated drainage for
to handle loads up to 178 psf(8.5 kN/m2) optimized self-cleaning
<:° Tested in extreme weather conditions—hail-impact tested High-transmissive glass with anti-reflective coating
and resistant to salt spray,frost,ammonia,dust and sand Long-term safety and guaranteed top performance—
Proven guarantee against hotspots and PID-free to 25-year linear performance warranty;20-year product
IEC 62804-1 warranty
SolarWorld Efhcell''PERC cell technology for the highest
possible energy yields
Fill V CO E
Quality Tested
MADE IN USA . , .
OF US&IMPORTED PARTS
tU.40045046
www.solarworld.com
Iii liii
Sunmodule Plus SOLARWORLD
SW 290 - 300 MONO
REAL VALUE
PERFORMANCE UNDER STANDARD TEST CONDITIONS(STC)*
SW 290 SW 295 SW 300
Maximum power P,,,a, 290 Wp 295 Wp 300 Wp
Open circuit voltage Vo, 39.6 V 39.8 V 40.0 V
Maximum power point voltage V,,vv 31.9 V 32.3 V 32.6 V
Short circuit current Is, 9.75 A 9.78 A 9.83 A
Maximum power point current Imvv 9.20 A 9.25 A 9.31 A
Module efficiency q,„ 17.3% 17.59% 17.89
Measuring tolerance(P,„,x)traceable to TUV Rheinland:+/-2%(TUV Power controlled,ID 0000039351) *STC:1000W/m2,25°C,AM 1.5
PERFORMANCE AT 800 W/m2,NOCT,AM 1.5
SW 290 SW 295 SW 300
Maximum power P,„ax 219.6 Wp 223.6 Wp 226.7 Wp
Open circuit voltage V, 36.7 V 36.9 V 37.0 V
Maximum power point voltage V„,vv 29.5 V 29.9 V 30.2 V
Short circuit current Is, 7.99 A 8.01 A 8.06 A
Maximum power point current I„,vv 7.43 A 7.47 A 7.52 A
Minor reduction in efficiency under partial load conditions at 25°C:at 200 W/m2,97%(+/-3%)of the STC efficiency(1000 W/m2)is achieved.
PARAMETERS FOR OPTIMAL SYSTEM INTEGRATION
?� ISO 9001
Power sorting OWp/+SWp • C£ ve . SO 400
��----- a tIA I roe C4 ed
Maximum system voltage SC II/NEC 1000 V '
Maximum reverse current 25 A - 37.8(961) ....-
Number
Number of bypass diodes 3 ■ T. _
4.20
Operating temperature -40 to+85°C (106.65)
i 4x-L.
Maximum design loads(Two rail system)* 113 psf downward,64 psf upward ,
•
712 00.26(6.6)
Maximum design loads(Three rail system)* 178 psf downward,64 psf upward (180.85)
*Please refer to the Sunmodule installation instructions for the details associated with these lead cases. j ° 0.35(9) 0
0
COMPONENT MATERIALS g
Cells per module 60 m
of
Cell type Monocrystalline PERC g
Cell dimensions 6 in x 6 in(156 mm x 156 mm) 0 iO
o
Front Tempered safety glass with ARC(EN 12150) rn
rn
Back Multi-layer polymer backsheet,white
v -I m
Frame Black anodized aluminum
J-Box I P65 •
Connector PV wire(UL4703)with Amphenol UTX connectors
Module fire performance (U L 1703)Type 1 : , 0 0.35 9 • 0 0
0 0 0 0 0
DIMENSIONS/WEIGHT THERMAL CHARACTERISTICS 11.32
(287.50)
Length 65.95 in(1675 mm) NOCT 46°C
• y .
Width 39.40 in(1001 mm) TC I,, 0.07%/C y 39.4(1001) -{
Height 1.30 in(33 mm) TC V„, -0.29%/C 1.30(33)
Weight 39.7 lb(18.0 kg) TC P„,„ -0.39%/C All units provided are imperial.SI units provided in parentheses.
ORDERING INFORMATION CERTIFICATES AND WARRANTIES
Order number Description IEC 61730 IEC 61215 UL1703 ,
Certificates
82000482 Sunmodule Plus SW 290 mono(black frame) IEC 62716 IEC 60068-2-68 IEC 61701 0
81000430 Sunmodule Plus SW 295 mono(black frame) Product Warranty 20 years 5
Warranties*
82000432 Sunmodule Plus SW 300 mono(black frame) Linear Performance Guarantee 25 years v,
tO
*Supplemental warranty coverage available through SolarWorld Assurance'e" o
Warranty Protection Program-www.solarworld.com/assurance o
SolarWorld AG reserves the right to make specification changes without notice.This data sheet complies with the requirements of EN 50380.