Report j/ Giy2Olc - Oa 12_
3 7 'i S w GL/%s h 5 .
RECEIVED
r� i nTM NOV 12 2015
Performance Applied CITY OFTIGARO
BUILDING DIVISION
Material Safety Data Sheet Arclin Surfaces, Inc.
HAYWARD,WI OFFICE and PLANT 15859 Dyno Drive,Hayward,WI 54843 Phone(715) 634-5057 Fax(715) 634-2361
TACOMA,WA OFFICE and PLANT 2144 Milwaukee Way,Tacoma,WA 98421 Phone(253) 572-5600 Fax(253) 627-2896
PORTLAND,OR OFFICE and PLANT 2301 No Columbia Blvd, Portland,OR 97217 Phone(503) 289-1111 Fax(503) 978-2607
EMERGENCY NUMBERS CHEMTREC 800-424-9300 Date Issued: March 19, 2007
Outside US:703-527-3887 Revised:
Section I - Material Identification
Product Name: DMO Product Code:All Melamine DMO Products
Product Description: Decorative Melamine Overlay Impregnated Paper
Chemical Name: Resin Impregnated Paper IUPAC: N/A CAS#: N/A UN#: Not Regulated
Section II - Hazardous Ingredients
Ingredients CAS# Weight% Exposure Limits
50-00-0 0.3 ppm ACGIH Ceiling
Formaldehyde Below Reportable Threshold 0.75 ppm OSHA PEL-TWA
Methanol 67-56-1 Below Reportable Threshold 200 ppm ACGIH TLV and OSHA PEL
•29 CFR Part 1910.1200(g)(2)(i)(C)(1),of the Occupational Safety and Health Administration(OSHA)Hazardous Communication Standard
H.M.I.S. RATINGS HEALTH - 1 FLAMMABILITY - 0 REACTIVITY - 0
Section III - Health Hazards I
Effects of Over Exposure:
Contact with skin may cause irritation or rash. Eye contact may cause slight irritiation or redness.
Heated vapors may cause irritation of the respiratory tract.
Primary Route(s) of Entry:
Inhalation of dust or fumes.
Formaldehyde, a component of this product, is classified as an IARC (International Agency for Research on
Cancer)Group I Human carcinogen(nose and pharynx)and a potential human carcinogen by U.S. agencies
NTP and OSHA.
Section IV - Emergency and First Aid Procedures I
Skin Contact: Wash with soap and water at once.
Eye Contact: Flush with water for 15 minutes and call a physician if irritation persists.
Inhalation: Remove to fresh air.
Ingestion: Not applicable.
In all cases if irritation persists, obtain qualified medical advice.
Date printed:Tuesday,September 18,2007 Page 1 of 3
Section V - Fire and Explosion Hazard Data
Flashpoint: Not applicable Auto-Ignition Temperature: 410 degrees C. / 770 degrees F.
Extinguishing Media:Water spray, Carbon Dioxide foam or Dry Chemical, as determined by surrounding fire
Special Fire Fighting Procedures: Self-contained breathing apparatus is required.
Hazardous decomposition products may include formaldehyde and
oxides of carbon, nitrogen, sodium and potassium.
Unusual Fire and Explosion Hazards: None.
Section VI - Spill or Leak Procedures
Steps to be taken in case material is released or spilled:
Collect material and place in a closed container.
Proper PPE (personal protective equipment) should be worn per Section VIII of this MSDS.
Waste disposal method:
At this time,this material would not be considered a hazardous waste as defined under the federal RCRA
regulations (40 CFR 261). However, caution should be taken as these regulations can change and state and
local regulations may vary to reclassify this waste. Material should always be disposed of in accordance with
federal, state, and local regulations.
For further information, contact your state or local solid waste disposal agency.
Section VII - Handling and Storage
Precautions to be taken in Handling and Storing:
Store in a cool, dry and vented space with packaging left intact until use.
Other precautions: Consult the product bulletin prior to using this product.
Section VIII - Special Protection Information
Respiratory Protection: Should be worn to prevent breathing dust or heated fumes.
Ventilation: Local exhaust and general ventilation recommended.
Protective Gloves: Suitable protective gloves should be worn to protect against skin contact and to
prevent paper cuts.
Eye Protection: Safety glasses are recommended.
Other Protective Equipment:As required to prevent prolonged or repeated skin contact.
Section IX - Physical Data
Appearance and Odor: White, Colored, or Printed Light Weight Impregnated Paper
Boiling Point: Not Applicable
Percent Moisture Content 2-10% Leachate Analysis (Wt%):
Evaporation Rate: Non-Volatile Leachate Formaldehyde: 0.00011
Vapor Density: Non-Volatile
Specific Gravity: Not Applicable Leachate Methanol: NA
Section X - Reactivity Data
Stability: Stable Conditions to Avoid:Warm storage and ignition sources
Incompatibility: None known Hazardous Polymerization: Will not occur
Hazardous Decomposition Products may include formaldehyde, and oxides of carbon, nitrogen, sodium
and potassium
Date printed:Tuesday,September 18,2007 Page 2 of 3
Section XI - Toxicological Information
When heating the paper,it will give off small amounts of volatile chemicals,primarily formaldehyde.
Permissible Exposure Levels:
Formaldehyde: OSHA has established a 0.75 ppm PEL for formaldehyde as an 8 hour TWA and a 2 ppm 15-minute STEL
(Short Term Exposure Limit).OSHA has also set a 0.5 ppm action level for formaldehyde(see OSHA
regulation 21 CFR 1910.1048 for specific information regarding workplace requirements).ACGIH ceiling for
formaldehyde is 0.3 ppm.
Carcinogenicity: Formaldehyde, a component of this product, is classified as an ARC(International Agency for Research on
Cancer) Group I Human carcinogen (nose and pharynx)and a potential human carcinogen by U.S. agencies
NTP and OSHA.
Section XII: Ecological Information
No Data Available
Section XIII: Final Disposition
Material should always be disposed of in accordance with federal,state and local regulations.See Section VI for further details.
Section XIV: Transport Information
This product is not regulated.
Section XV: Regulatory Information 1
This product contains no hazardous ingredients above reportable thresholds as designated in the reporting requirements of'Section
312 and 313 of the Emergency Planning and Community Right to Know Act'of 1986(40 CFR 370 and 372).
Section XVI: Other Information
DISCLAIMER:The information and recommendations contained herein are offered as a service to our customers but are not intended to relieve the user
from its responsibility to investigate and understand other pertinent sources of information and to comply with all laws and procedures applicable to the safe
handling and use of these matenals The information and recommendations provided herein are believed by Ardin Surfaces,Inc.to be accurate or obtained
from sources believed to be reliable.However,Arclin Surfaces,Inc.makes no warranty concerning their accuracy and Arclin Surfaces,Inc.will not be liable
for claims resulting to any party's use of or reliance on information or recommendations contained herein regardless of whether it is claimed that the
information or recommendations are inaccurate,incomplete or otherwise misleading.
Date printed:Tuesday,September 18,2007 Page 3 of 3
MATERIAL SAFETY DATA SHEET
BOISE CASCADE Boise Cascade
•
SECTION 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME:
WOOD DUST (UNTREATED).
TRADE NAME:
WOOD DUST (UNTREATED).
MANUFACTURER/DISTRIBUTOR: BOISE CASCADE
P.O. BOX 62
BOISE, ID 83707-0062
PHONE NUMBER: 208/384-6610
DESCRIPTION:
PARTICLES GENERATED BY ANY MANUAL OR MECHANICAL CUTTING OR ABRASION PROCESS
PERFORMED ON WOOD.
SECTION 2 COMPOSITION, INFORMATION ON INGREDIENTS
COMPONENT OSHA PEL ACGIH TLV
WESTERN RED CEDAR 15MG/M3 TWA 0.5MG/M3(INHALABLE)
(TOTAL DUST)
• 5.0MG/M3
(RESPIRABLE FRACTION)
ALL OTHER SPECIES TWA-15MG/M3 1.0MG/M3(INHALABLE)
(TOTAL DUST)
5.0MG/M3
(RESPIRABLE FRACTION)
SECTION 3 HAZARDS IDENTIFICATION
SKIN & EYE CONTACT:
EYE IRRITATION & DERMATITIS WOOD DUST CAN CAUSE EYE IRRITATION. VARIOUS SPECIES OF
WOOD DUST CAN
ELICIT ALLERGIC CONTACT DERMATITIS IN SENSITIZED INDIVIDUALS.
INGESTION: NOT APPLICABLE
SKIN ABSORPTION: NOT KNOWN TO OCCUR.
INHALATION:
MAY CAUSE NASAL DRYNESS, IRRITATION & OBSTRUCTION, COUGHING, WHEEZING,&
SNEEZING. SINUSITIS & PROLONGED COLDS HAVE ALSO BEEN REPORTED.
• CHRONIC EFFECTS:
WOOD DUST, DEPENDING UPON SPECIES, MAY CAUSE DERMATITIS ON PROLONGED,
REPETITIVE CONTACT; MAY CAUSE RESPIRATORY SENSITIZATION AND/OR IRRITATION. WOOD
DUST IS LISTED IN THE NATIONAL TOXICOLOGY PROGRAM ANNUAL REPORT ON CARCINOGENS.
IARC CLASSIFIES WOOD DUST AS A CARCINOGEN TO HUMANS (GROUP 1). THIS CLASSIFICATION
IS BASED PRIMARILY ON IARC'S EVALUATION OF INCREASED RISK IN THE OCCURRENCE
OF ADENOCARCINOMAS OF THE NASAL CAVITIES PARANASAL SINUSES ASSOCIATED WITH
EXPOSURE TO WOOD DUST. IARC DID NOT FIND SUFFICIENT EVIDENCE TO ASSOCIATE
CANCERS OF THE OROPHARYNYX, HYPOPHARYNX, LUNG, LYMPHATIC AND HEMOTAPOETIC
SYSTEMS, STOMACH COLON OR RECTUM WITH EXPOSURE TO WOOD DUST.
SECTION 4 FIRST-AID MEASURES
INHALATION:
REMOVE TO FRESH AIR. IF PERSISTENT IRRITATION, SEVERE COUGHING OR BREATHING
DIFFICULTY OCCURS, GET MEDICAL ATTENTION.
EYE CONTACT:
REMOVE CONTACT LENSES (IF APPLICABLE). FLUSH EYES, INCLUDING UNDER
EYELIDS, WITH LARGE AMOUNTS OF WATER. REMOVE TO FRESH AIR. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION.
SKIN CONTACT:
WASH AFFECTED AREAS WITH SOAP AND WATER. IF RASH OR PERSISTENT IRRITATION OR
DERMATITIS OCCURS, GET MEDICAL ATTENTION.
INGESTION: NOT APPLICABLE.
•
SECTION 5 FIRE FIGHTING MEASURES
FIRE AND EXPLOSION
FLASH POINT: NOT APPLICABLE.
AUTO IGNITION TEMPERATURE: DEPENDENT UPON DURATION OF EXPOSURE TO HEAT SOURCE
AND OTHER VARIABLES. 400 DEG. - 500 DEG. F (204 DEG. - 260 DEG. C).
FLAMMABLE LIMITS IN AIR (% BY VOLUME): AN AIRBORNE CONCENTRATION OF 40 GRAMS OF
DUST PER CUBIC METER OF AIR IS OFTEN USED AS THE LOWEST EXPLOSION LIMIT (LEL)
FOR WOOD DUST.
UNUSUAL FIRE AND EXPLOSION HAZARD:
WOOD DUST IS A STRONG TO SEVERE EXPLOSION HAZARD IF A DUST "CLOUD" CONTACTS AN
IGNITION SOURCE.
SPECIAL FIRE FIGHTING PROCEDURES:
BURNS LIKE OTHER WOOD PRODUCTS, ALTHOUGH IT IS DANGEROUS AND MAY BURN HOTTER.
PARTIALLY BURNED DUST IS ESPECIALLY HAZARDOUS IF DISPERSED INTO THE AIR. REMOVE
BURNED OR WET DUST TO AN OPEN AREA AFTER FIRE IS EXTINGUISHED. WET DOWN WOOD
DUST TO REDUCE THE LIKELIHOOD OF IGNITION OR DISPERSION OF DUST INTO THE AIR.
' EXTINGUISHING MEDIA:
WATER, CARBON DIOXIDE, SAND.
SECTION 6 ACCIDENTAL RELEASE MEASURES
SWEEP OR VACUUM DUST FOR RECOVERY OR DISPOSAL. WOOD DUST CLEANUP AND DISPOSAL
ACTIVITIES SHOULD BE ACCOMPLISHED IN A MANNER TO MINIMIZE CREATION OF AIRBORNE
DUST. PROVIDE GOOD VENTILATION WHERE DUST CONDITIONS MAY OCCUR. PLACE RECOVERED
WOOD DUST IN A CONTAINER FOR PROPER DISPOSAL.
SECTION 7 HANDLING AND STORAGE
AVOID DUSTY CONDITIONS AND PROVIDE GOOD VENTILATION. AVOID EYE CONTACT. AVOID
REPEATED OR PROLONGED CONTACT WITH SKIN. CAREFUL BATHING AND CLEAN CLOTHES ARE
INDICATED AFTER EXPOSURE. AVOID PROLONGED OR REPEATED BREATHING OF WOOD DUST IN
THE AIR. AVOID CONTACT WITH OXIDIZING AGENTS AND DRYING OILS. AVOID OPEN FLAME.
SECTION 8 EXPOSURE CONTROLS, PERSONAL PROTECTION
PERSONAL PROTECTIVE EQUIPMENT:
RESPIRATORY PROTECTION:
WEAR NIOSH-APPROVED RESPIRATOR WHEN THE ALLOWABLE OSHA EXPOSURE LIMITS TO
WOOD DUST MAY BE EXCEEDED.
EYE PROTECTION:
RECOMMEND GOGGLES OR SAFETY GLASSES AS CONDITIONS INDICATE.
SKIN PROTECTION:
OTHER PROTECTIVE EQUIPMENT, SUCH AS GLOVES AND OUTER GARMENTS, MAY BE NEEDED
TO REDUCE SKIN CONTACT. WASH AFFECTED AREA OF THE BODY AFTER CONTACT WITH DUST.
OTHER CLOTHING AND EQUIPMENT:
NOT APPLICABLE.
ENGINEERING CONTROLS:
VENTILATION REQUIREMENTS:
PROVIDE LOCAL EXHAUST, AS NECESSARY, TO MEET OSHA REQUIREMENTS FOR ALLOWABLE
EXPOSURE LIMITS.
OTHER TYPES OF ENGINEERING CONTROLS:
DUE TO THE EXPLOSIVE POTENTIAL OF WOOD DUST WHEN SUSPENDED IN AIR, PRECAUTIONS
SHOULD BE TAKEN TO PREVENT SPARKS OR OTHER IGNITION SOURCES IN VENTILATION
EQUIPMENT.
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL FORM: SOLID
COLOR:
LIGHT TO DARK TAN-COLORED GRANULAR SOLID. COLOR AND ODOR ARE DEPENDENT
UPON WOOD SPECIES AND TIME SINCE DUST WAS GENERATED.
ODOR: COLOR AND ODOR ARE DEPENDENT UPON WOOD SPECIES AND TIME SINCE DUST WAS
GENERATED.
BOILING POINT: NOT APPLICABLE
MELT POINT/FREEZE POINT: NOT APPLICABLE
PH: NOT APPLICABLE.
SOLUBILITY IN WATER: INSOLUBLE
SPECIFIC GRAVITY: VARIABLE (DEPENDENT ON WOOD SPECIES AND MOISTURE CONTENT).
EVAPORATION RATE: NOT APPLICABLE.
VOLATILE BY VOLUME: NOT APPLICABLE.
VAPOR PRESSURE: NOT APPLICABLE
VAPOR DENSITY: NOT APPLICABLE.
SECTION 10 STABILITY AND REACTIVITY
CONDITIONS CONTRIBUTING TO INSTABILITY:
STABLE UNDER NORMAL CONDITIONS. WOOD DUST GENERATED FROM SAWING, SANDING, OR
MACHINING THE PRODUCT IS EXTREMELY COMBUSTIBLE. KEEP IN COOL, DRY PLACE AWAY
FROM IGNITION SOURCES.
INCOMPATIBILITY (MATERIALS TO AVOID): AVOID CONTACT WITH OXIDIZING AGENTS AND
DRYING OILS. AVOID OPEN FLAME. PRODUCT MAY IGNITE AT TEMPERATURES IN EXCESS OF
400 DEG.
HAZARDOUS DECOMPOSITION PRODUCTS:
THERMAL-OXIDATION DEGRADATIVE OR BURNING OF WOOD CAN PRODUCE IRRITATING AND
POTENTIALLY TOXIC FUMES AND GASES, INCLUDING CARBON MONOXIDE, ALDEHYDES, ORGANIC
ACIDS, AND NITROGEN COMPOUNDS.
CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
SECTION 11 TOXICOLOGICAL INFORMATION
WOOD DUST:
- WOOD DUST MAY CAUSE NASAL DRYNESS, IRRITATION, AND OBSTRUCTION. COUGHING,
WHEEZING, AND SNEEZING; SINUSITIS AND PROLONGED COLDS HAVE ALSO BEEN REPORTED.
DEPENDING ON SPECIES, MAY CAUSE RESPIRATORY SENSITIZATION AND/OR IRRITATION.
WOOD DUST IS NOT CONSIDERED A POTENTIAL CANCER HAZARD BY OSHA OR THE NATIONAL
TOXICOLOGY PROGRAM (NTP). THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC)
' CLASSIFIES WOOD DUST AS A CARCINOGEN TO HUMANS (GROUP 1). THIS CLASSIFICATION IS
BASED PRIMARILY ON IARC'S EVALUATION OF INCREASED RISK IN THE OCCURRENCE OF
ADENOCARCINOMAS OF THE NASAL CAVITIES AND PARANASAL SINUSES ASSOCIATED WITH
EXPOSURE TO WOOD DUST. IARC DID NOT FIND SUFFICIENT EVIDENCE TO ASSOCIATE
CANCERS OF THE OROPHARYNX, HYPOPHARYNX, LUNG, LYMPHATIC AND HEMATOPOIETIC
SYSTEMS, STOMACH, COLON, OR RECTUM WITH EXPOSURE TO WOOD DUST.
SECTION 12 ECOLOGICAL INFORMATION
NOT APPLICABLE.
SECTION 13 DISPOSAL CONSIDERATIONS
THIS PRODUCT IS NOT CONSIDERED HAZARDOUS WASTE UNDER FEDERAL HAZARDOUS WASTE
REGULATIONS 40 CFR 261. STATE AND LOCAL REQUIREMENTS FOR WASTE DISPOSAL MAY BE
DIFFERENT FROM FEDERAL REGULATIONS. INCINERATE OR LANDFILL IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
HAZARDOUS WASTE DESIGNATION: NOT APPLICABLE.
SECTION 14 TRANSPORT INFORMATION
DOT (DEPARTMENT OF TRANSPORTATION)
PROPER SHIPPING NAME: WOOD DUST.
HAZARD CLASS: COMBUSTIBLE.
IDENTIFICATION NUMBER: NOT APPLICABLE.
SECTION 15 REGULATORY INFORMATION
TSCA (TOXIC SUBSTANCE CONTROL ACT):
NOT APPLICABLE.
CERCLA (COMPREHENSIVE RESPONSE COMPENSATION AND LIABILITY ACT):
NOT APPLICABLE.
SARA TITLE III:
FEDERAL AND/OR STATE REGULATIONS MAY REQUIRE REPORTING.
SECTION 16 OTHER INFORMATION
WOOD DUST IS NOW OFFICIALLY REGULATED AS AN ORGANIC DUST UNDER THE PARTICULATES
NOT OTHERWISE REGULATED (PNOR) OR INERT OR NUISANCE DUST CATEGORIES AT PELS OF:
TWA- 15.0 MG/M3 (TOTAL DUST); 5.0 MG/M3 (RESPIRABLE FRACTION). HOWEVER, A
NUMBER OF STATES HAVE INCORPORATED PROVISIONS OF THE 1989 STANDARD IN THEIR
STATE PLANS. ADDITIONALLY, OSHA HAS ANNOUNCED THAT IT MAY CITE COMPANIES UNDER
THE OSH ACT GENERAL DUTY CLAUSE UNDER APPROPRIATE CIRCUMSTANCES FOR
NONCOMPLIANCE WITH THE 1989 PELS.
MSDS STATUS: UPDATED TO NEW FORMAT.
REFERENCES:
THRESHOLD LIMIT VALUES FOR CHEMICAL SUBSTANCES AND PHYSICAL AGENTS AND
BIOLOGICAL EXPOSURE INDICES FOR 1998
NIOSH POCKET GUIDE TO CHEMICAL HAZARDS FOR JUNE 1997
HAZARDOUS CHEMICALS DESK REFERENCE, THIRD EDITION, RICHARD J. LEWIS, SR.
THIS MATERIAL SAFETY DATA SHEET IS OFFERED SOLELY FOR YOUR INFORMATION,
CONSIDERATION AND INVESTIGATION. WHILE THE INFORMATION AND RECOMMENDATIONS SET
FORTH HEREIN ARE BELIEVED TO BE CORRECT, THE BOISE CASCADE CORPORATION PROVIDES
NO WARRANTIES, EITHER EXPRESSED OR IMPLIED, AND ASSUMES NO RESPONSIBILITY FOR THE
ACCURACY OR COMPLETENESS OF THE DATA CONTAINED HEREIN.
CURRENT ISSUE: 03/29/10
PREVIOUS ISSUE: 03/09/09
•
r . • ,
0
0
Seasonal Kiosk `' - `_ ,.• '`.R
Fixture Finish - Antique White Melamine 409EverpreenDrNe
Bommer Hinge Norlh lonneNle,WA
Counter Top Finish - Antique White Melamine j11111 ►.
#BOM 7514H Zinc 96639
,1so94s7leoo
/ www.sllver cabineb.com
LONRDEMNL• Folding Table iNt d owinpond the MmmaHOn a em melhe e.clu.ive O�oPeih of 5dvei Sla CaChett Any 72L x 30W x 29H� DN1E11S1DNet•
Al tlmenuons ue m mcn uNeu noted
4.,,,4 oPap OMER:
�� #BOM 75H4H Zinc
RECEIVED
DETAIL E
4,,fri„.„,„,„vok
SCALE 1 : 12 NOV 1 2 2015
CITY OF TIGARD
BUILDING DIVISION 41118:1010P IIIIIIIIIIIIII
/
ENGINEER
WC9M
Folding Table �� DATE:
Fr
IIIIII 72L x 30W x 29H 7/22/2015
PROJECT/LOCATION:
�' �� Seasonal Kiosk
„,,,it
ii144...
4
.-.A1k .10"
1%( 11.11111'-----r. REFERENCE t:
DESCRIPTION:
Seasonal Kiosk-Master
Assembly-Final
Assembly t: REV t:
1
SHEET SCALE: ':24
SHEET:
1 OF 2
104" -
409 Evergreen Drive
North Bonneville,WA
98639
52" 52" Phone:(509)427 8800
B—.a._ 104" - www.silverstareabinets.com
72" — 16" —
CONFIDENTIAL
16" --- 16" -- �—4" r�I,diawinp and Ih<�nlarmalian ner<n a,e.he
i 6 O excWdomio oeiwse of sitar camne0 my
4 J e?,a Press wi��<c.
r. 3 4 onsent a sl��U Iortidden.
._,ag I 1 II - DIMENSIONS:
liii �1 1�t�� en,w
I �I"enrne � nalla,<al��nk„naI<d
,'ti I'� 30” CUSTOMER:
-4 — �., 27-3.. Papyrus
TT 33
29n 30"
.
72" A � " A A 104„ �I
i
r
''°,gv SECTION A-A
;ken Y,',,,s*k Ste.
R
16" 12" ENGINEER:
w974 r B DATE:
7/22/2015
34" 36" J 34"
PROJECT/LOCATION:
Seasonal Kiosk
3.. 16" 72" 16"
REFERENCE#:
'
I
1 DESCRIPTION:
27-4" Seasonal Kiosk-Master
Assembly-Final
iiIIIIIFIl
=,
Gate Assembly#: REV#:
5 4 SECTION B-B 1
SHEET SCALE: 1:24
SHEET:
2 OF 2