Loading...
Specifications�a z 0 c� z 0 c� O a x a x Q F w � t tn d U x W w a Yti N Q �` CD eq l.� eq a W m z U a cs� � F o a � a U F U a A p. W � U Z z o � F a a � z w w C7 A U S D 4 GENERAL STRUCTURAL NOTES CODE REQUIREMENTS: CONFORM TO THE 2012 INTERNATIONAL BUILDING CODE AS AMENDED BY THE 2014 OREGON STRUCTURAL SPECIALTY CODE,REFERENCED HEREAFTER AS IBC. DESIGN CRITERIA: DESIGN WAS BASED ON THE STRENGTH AND DEFLECTION CRITERIA OF THE IBC. IN ADDITION TO THE DEAD LOADS,THE FOLLOWING LOADS WERE USED FOR DESIGN,WITH LIVE LOADS REDUCED PER IBC: GROUND SNOW LOAD Pg: 10 PSF MINIMUM ROOF SNOW LOAD:25 PSF BASIC WIND SPEED(3-SEC GUST,ULTIMATE): 120,EXPOSURE B SITE CLASS:D(ASSUMED) SDS=0.720 ap=2.5 Rp=6.0 EXISTING CONDITIONS: THE CONTRACTOR SHALL FIELD VERIFY ALL EXISTING CONDITIONS,DIMENSIONS AND ELEVATIONS. THE CONTRACTOR SHALL NOTIFY THE ARCHITECT/ENGINEER OF ANY DISCREPANCIES FROM CONDITIONS SHOWN ON THE DRAWINGS PRIOR TO THE START OF THE WORK. TEMPORARY CONDITIONS: THE CONTRACTOR SHALL BE RESPONSIBLE FOR STRUCTURAL STABILITY OF THE NEW AND EXISTING STRUCTURES AND WALLS DURING CONSTRUCTION. THE STRUCTURE SHOWN ON THE DRAWINGS HAS BEEN DESIGNED FOR STABILITY UNDER THE FINAL CONFIGURATION ONLY. CARPENTRY: SAWN LUMBER DESIGN IS BASED ON THE NATIONAL DESIGN SPECIFICATION,LATEST EDITION. SAWN LUMBER SHALL CONFORM TO WEST COAST LUMBER INSPECTION BUREAU OR WESTERN WOOD PRODUCTS ASSOCIATION GRADING RULES FRAMING ACCESSORIES AND STRUCTURAL FASTENERS SHALL BE MANUFACTURED BY SIMPSON STRONG-TIE COMPANY (OR ENGINEER APPROVED EQUAL)AND OF THE SIZE AND TYPE SHOWN ON THE DRAWINGS AND ATTACHED PER MANUFACTURER'S REQUIREMENTS AND RECOMMENDATIONS UNLESS NOTED OTHERWISE. HANGERS NOT SHOWN SHALL - BE SIMPSON HU OF SIZE RECOMMENDED FOR MEMBER. ALL FRAMING NAILS SHALL BE COMMON NAILS. NO BOX NAILS ALLOWED. FASTENERS AND ACCESSORIES IN CONTACT WITH PRESERVATIVE TREATED WOOD MUST BE HOT DIPPED GALVANIZED OR HAVE ZMAX COATING. SHEATHING PANELS SHALL CONFORM TO THE REQUIREMENTS OF VOLUNTARY PRODUCf-STANDARD PS 1 OR PS 2,OR APA PRP-108 PERFORMANCE STANDARDS. UNLESS NOTED,PANELS SHALL BE APA RATED SHEATHING,EXPOSURE 1,OF THE THICKNESS AND SPAN RATING SHOWN ON THE DRAWINGS. INSTALLATION SHALL BE IN CONFORMANCE WITH APA RECOMMENDATIONS. ALLOW 1/8" SPACING AT PANEL ENDS AND EDGES,UNLESS OTHERWISE RECOMMENDED BY THE PANEL MANUFACTURER. ALL ROOF SHEATHING SHALL BE INSTALLED WITH FACE GRAIN PERPENDICULAR TO SUPPORTS. ROOF SHEATHING SHALL EITHER BE BLOCKED,TONGUE-AND-GROOVE,OR HAVE EDGES SUPPORTED BY PLYCLIPS. MECHANICAL: THE CONTRACTOR SHALL COORDINATE SEISMIC RESTRAINTS OF ELECTRICAL EQUIPMENT,MECHANICAL,PLUMBING, FIRE SPRINKLER,MACHINERY,AND ASSOCIATED PIPING WITH THE STRUCTURE. ANY CONNECTIONS TO STRUCTURE NOT CONFORMING TO SHEET METAL AND AIR CONDITIONING CONTRACTORS NATIONAL ASSOCIATION(SMACNA),OR SPECIFICALLY DETAILED ON THE MECHANICAL ENGINEER'S DRAWINGS,SHALL BE DESIGNED IN ACCORDANCE OF THESE GENERAL NOTES,BY AN ENGINEER REGISTERED IN THE STATE OF OREGON,AND SHALL BE SUBMITTED TO THE ARCHITECT/ENGINEER PRIOR TO FABRICATION. FLASHING AND WATERPROOFING: ALL FLASHING AND WATERPROOFING SHALL BE BY OTHERS UNLESS NOTED OTHERWISE ON THE PLANS. 11\AKTM RIPPEY Consulting Engineers By: JW Date: 7650 SW Beveland Street FOUGHT STEEL RTU'S Chk By: Date: Suite 100 Job#: 19230 Tigard,Oregon 97223 Phone:(503)443-3900 Sheet: Ni Of: n r I EXISTING WIDE FLANGE COLULMNS TYP. 1. -,„144 ,t,....:,‘,1'2' �' - � REMOVE EXISTING EQUIPMENT AND t —'4'''' ''''' . tr PROVIDE PLATFORM CONSTUCTED ABOVE ROOF TO SUPPORT NEW EQUIPMENT. SEE DETAIL 1/SK2. II - (2) NEW 12.5 TON UNITS WEIGHING - — - � 1392 LBS. (INCL. CURB) � � - 1 NEW 6 TON UNIT,,„EI 61)1,itte_.,, / .)(i" G. . GHING 810 •it - l' ' LBS (INCL. CURB. - .- .. - .. 851rir..),S)ci.t. 2PE 11 J OREGON co a 4' cnP 04 ., ' w .x:. ` rifj, i T. 1 9 , \� WO - — YL E „ -r..;:,_ .,..„ - — 4. EXP: 6/30/20 R i i EXISTING WIDE FLANGE -I. 4 :..,'• 7.,,, , t 1BEAMS, TYP. 1 EXISTING PLANK DECKING SPANNING i ' ill '' ',-: ' - * 1 !-., -.;: ''' , ' - ii'-:,i BETWEEN JOISTS. i; t k EXISTING WIDE FLANGE / • JOISTS, TYP. EXISTING OPEN WEB STEEL JOISTS, TYP. SITE A ,,,,. DDRESS: 14255 SW 72ND AVE. TIGARD, OR _ ...... --:, 1 SITE/ROOF PLAN SK1 NTS �� TM RIPPEY BY JW DATE CONSULTING ENGINEERS FOUGHT STEEL - RTU'S CHK BY DATE 7650 S.W. Beveland St, Suite 100 SOB Na 19230 Tigard,Oregon 97223 Phone(503)443 3900 SHEET SK of w.; --. I I 1 I I � ,•1_. , ! I 1 I KEY,, Ei s 1 t I i .` I I .... I... I .'_. 1 1 1 1 ' I I i .... I ' 1 I I � i I I I1 I. I f r I 1 1 ; I 1 1 i ! f 1 i i i , , , 1 4i PT.HF#2 PLATFORMSEAM'SP NNING. , , 1 111 i 1 1111 II ` I i I I r -, " ' _ 1 1 1 I ! , ,_ { -$ TWEE XISET�Nta WFB Iv�Si I�ELOW AI�DI { I l - • 1 I A7TAOHE DtR l L TO E)�I TINGiROOF i i * i 1.. ' , 1 , I ..I... ; Ci:/4" 11MUMIDEPTH'OFIBEAM SHALUBE' E M D CK NI i ; 1 AM1 AT I I ; i I 1 1 1 1 I i I 11 � 0�. ,�O�ATE W giLT.i.71:1:411pli.s. 11..;N(y1 \4 ISTI G { i I r l I I I I ) ! ! I I IHaINEERFINO�.Pi I LE ' ' I I i I . I ; 1 I : , 1 I i ... I ; 1 I I I I , 1 .� 1 1 1 1 �.. IH 1 1 1 I L_" I I ._ I I 1 1 I 1-1 1 i - iNIf II Mi 4 C Ply�IF1# EA0t H[I HT ; 1 I 1 I 1 , I--; . 1 i I C � 11 1 1 I1 i I , . I I 1 �__i I 1 I I _f. i I I I ' 1PIAjFFOR�VI CLO TURF BEAIML • , . I II I II 1 1 I l l 1 (.-_ � _ 1 1 ! 1 1 1 •i 1 1 1 � I I ) 1 1 1 ` I ; l 1 I . " � .. I*ib I I (BY$UP I ALtGN'EDG Si. I _ i. 1 I i I I ;11; I , 1 1 I , I ! Ill p S; W IGHT 1 r 1 I � i '• I 1 L i d�pHM- E� - 92. 1 . B SK� . , , - ; I IN L�D�NG!CU�tE�S APRRXOiMATEILy 13 1 1 i I ' 1 f 'i I ' I LBS MAX UNIT MAY BE:LOCATEb 1 . I 1 1 1 1 I 1 YVIFHER -F�LONO 7NEIN1EW .TEQFrI < I I i -p -'i 1 i 1 ,.-, , , 1 "T ,..� I. !. SAI�Y PROVIDE NEW I 0 I G1 I 1 11 1 11 1 OPENING CEJ tN:EXISTIN� ALAN�,D�`w�IN 4 Fi E _E i ! R D TING, 4�-d x 4-D e FO -UC ; • SK4 1 5-LAT EDGES OF OPENING PROVIDE ' i I TYP ' 1. ' MI IMJFA 4x P.TII F#2 YULE HEIGHT HEADER ; 1 I I - .1 i I _ _ _ _ .` ,..,:• , 1H14NG WEAR€R SACH E�Jd WI7+l (14� I I I TYP - �; W; ' ..1 SI�IIPSON.A35 QL1PS, (2) EACH SIDE OF I 1 I__. 1 , H 1 ; 1 ; i ' , ; -6. .INFILL PLATFORIM WITH MINIiAUIVI 2x4 PT ' I I I I ' 1 HF#2 JOISTS C«3 2i'-0"OfC'MAX.!SPANNING 1 r 111 1 i 11 ' 1 WIDTH OF` PLATFOI�M.1 HANG WITH , I SIMPSON'LUS24 HANGERS. COVER I PLATFORM WITH MINIMUM 1/2" PLYWOOD I . I BREATHING NAILED AT ALL Sl1JP,PORTS WITH - Ifr 1 ;64; \' ! iii,riii qs, ! , , . , , , , , , , , , , , , , 7. i EXISTING WF SEAMS @ 11'-4" 0/C MAX. : : : . N 1/SKI - i ' E ROOF PLA f1 � I OREGON ' , EXISTING WIDE FLANGE COLUMN BELOW, • 8. EX / ��,a ® _' , I R VIDE SOLID WOOD BEARING BLOCKIN`G� 1 P O I l I t,9 �� I , , I 1 , 1 , ; , 1 I ; $4TINEEN TOP,O COLUMN ANCA I ' 4(Y,[ 1 W , , -,,,_4-- -;;1-7, UNDERSIDE OF EXISTING PLANK DECK. 1 1 I ' ' : 1 ; SCREW'PLANK DECKING TO BLOCKING. 0 IARPROOEING B {QTHERS.ECP: 16f30/2NOTE:ALLWTE :I i I i i I 1 1 , , ,1 I 1 ! ! ! ! ! : ! !;; ; ; ; ; ; : i '- , I I 1 I { 1 J--. 1 I— RTU PLATFpIIA1111 PLAT : i , 1 ; 1 SK2 1 , ,_, I 1hTTS I 1 1 I f I 1 Iiiii I III , 1 1 1 1 ; � i l , i, I 1 ( ' ' i I I ' I i ( . I I S , I 1 I , I : ; ! I TITIN.. ' III I , I II III ! I ' 1 ! I , , 1 , : I II I � I I I 1 I I ,-I 1 !, , 11 I I I 1 I I i I 1 6 , 4.. , • r , -I i 1 I i , I � I. I I 1 i I I I i ' I... 1111 .. 1 III i I , ( I #.11V1T M RIPPEY BY JW DATE - P.,1,... °°NS"ITINGENGn�E'� FOUGHT STEEL - RTU'S CHK BY DATE 7650 S.W.Beveland St, Suite 100 JOB NO 19230 Tigard,Oregon 97223 Phone(503)443-3900 SHEET SK2 OF 6G446) PRFs iJ ocs.NEED?0 . 8512PE '!� /s OREGON e, 6.-- �' 4 ✓,/' �• 19 , ��% 3, it 1441 �Yl E 16-\ 'h EXP: 6/30/20 0 EITHER EQ. ► SPACED OR BOTH WAYS 4 TYP. MECHANICAL UNIT BY OTHERS 16 a4. CLIP 16 GAUGE SEISMIC CUP N.T.S. 16 GA. CLIPS W/ (S) *10 TEK SCREWS PER CLIP, (4) CLIPS REQ'D. SEE PLAN VIEW FOR \ ` -1 r/r/l1 CLIP LOCATION '�•-�, i' ,11 I'-0", TYP. -•8 if WOOD BLOCKING _�' CLIP REQUIRED 1111111111 LOCATION (4) TOTAL FLASHING AND INSULATIONMECI-I. UNIT NOT SHOWN FOR CLARITY OUTLINE WATERPROOFING BY OTHERS PLAN VIEW N.T.S. PLATFORM SHEATHING / /1 C---- .PER PLAN PLATFORM JOISTS PROVIDE *10 SCREWS ' - _ PER PLAN 1'-0" 0/C AND AT 6" FROM CENTER CURB ON NEW ENDS OF CURB. MINIMUM 2 " PLATFORM MEMBER EMBED INTO STRUCTURAL MEMBER, TYP. ATTACH NEW PLATFORM PERIMETER MEMBERS TO TOP OF EXISTING DECK EXISTING 2X WITH SIMPSON A34 CLIPS W/(8) #9 x 1 1/2" PLANK DECK. SIMPSON SD SCREWS. MINIMUM (2) CLIPS ON SHORT SIDES OF PLATFORM AND (4) CLIPS ON LONG SIDES. CLIPS MAY BE ON SH CT I ON AT cI I INTERIOR OR EXTERIOR SIDE. RTU-01 U SCALE: 11/2" = 1'-0" 1 ' 1M TM RIPPEY BY JW DATE CONSULTING ENGINEERS FOUGHT STEEL - RTU'S CHKBY ATE 7650 SW Beveland,Suite 100 Tigard,Oregon 97223 Jon NO 19230 Phone:(503)443-3900 Fax:(503)443-3700 SHEET SK3 OF . i__I 1 I 1. 1.. I. { i' . i 1 1 I � I S I I I � � I I I t I ' � i ; .I I 1 1 ....1 r I i I ..... I i 1,1 hi41 I I I' H 1 ..I ; I. , I I 1 I j ; ' I I - 1 I I ! 1 1 I :, 1 I I I ' • ! : , I I I 1 1 I I I i : I 1I i �_ ._ 1 i i { ' .1 ' . i j I , I1 _I I I I I I I I I f PLA,F iiin orI'ArHI1 G I : 1 { I1 ! I I 1. 1 i. 1 ! !. i �EfR._�{./'i ! _ - ! !... , t i.., f ` i ! .;... I i -T 1-"T--1-i ! I } _ i , i ' `.... ! 1 1-.. i , f J-. 1 1 • 'i . 1 - -- , I li inn , , i 1 I I I I I 1111 ' 1H11111 I I I ; 11 ' 1 ! ; ; ; ; ; ; 1; 1 11 1 '• I,. 1 1. , 1 1 1 I 1 11 1 , 1 , 11 II• 11 1111 1, 1 i , f , I 1 . LI ' i i 1 I !. i TFFORiMIrBEAI1A , i 1 1 - , - , 1 , i I I 1 i 1_ F 1 BEYOND PER PLAN I I 1 I I , I , ., , 1 , 1 I I ' 1 I f,. 1 ' , I , I 1 , 1 1 1 I o 1 1 1. ` L s ) s I L 1 I i.. 1 1 ' i i 1 1 1 1 1 1._.11 I_ i 1 1, 1 s I ._ 4 1 1 i I 1 1 I_-, 1 1 t I--_ I ; _.L.. 1_...- I 1 1 I .1 { 1 I 1 I-...I I I I ( i II � ( I I I , , �� I { I I I I I 11 I1 I i ' i I j I � 1 , , ' ; 1 1 : .I 11 � 1 1 4x HEAOEF"i I FR PLAN I I , 1 I I I I I .1 i i ,_ I I { I 11 ATTACHED To PLATFORM 1 I 1 1 1 1 I " 1 E3AM BEYOND WI ii 1. i CLIF? ISR PLAN I I I I I c 1 � 1 { 11 I _ � 1I 1 I II II1 1 ' I ` 1 i,, ! , ! ,, , ,, , , , i1 , 11 , 11 ,„I I. , 1 1 I I I , i I i i.... 1 1 I , I 1 I f 1 i II j ,, .I I : I. I i 1 I I_ 1 _ 1 . I I ', j I _ I i i ; I 11 "�i I MECHANICAL©RENJf4Q, ' I , I ,. 1 ' f ; 1 . , 1 1 N , r 1 I SEE PtA 1 I ` 1 I 1 1 I ' 1 1 „ 1 ", " ; ; ; ;; ; ; ;I ' I - - , L I - t , I i . I I I , I I 1 I I 1 - - 1 i II I� I ATTACH ENbs0,,CUT PLANKS ��. i � E . S/- 1-1 I TO BOTTOM yF NEW HEADER , .4,� �EXISTING PLANK , 1 WITH (204" s 3" EMBED ! 8512'E, lDECK I sIIVIPsoN sus sOEWS AT, EACH PLANK PRE DRILL I I ; .. E'i dN' 7, ,,,„, ,• ,.,,, ,,,, , ,,, , , „ .,, I j-, I i. l 11, , ( I .1 , I I i j , c8) 1 I� ` 1 I ,. J�',0 DR IG� ,, ,,,, , ,, .,., , , , , „ , , I 1 I I, "", , , I ri(j9 , , , I 9h ' I I I ,„ ,,,, , , , 1 . I 1 I i tI 1, 1 !E (17, •':, 6 3902© 1 I 1 -I 1 ' I 1 , • I , , . • I 1 ; ;. : I 1 I II I I C 0 ' ATFOR +�:N ; ' FRAMING E�C1`I A OPEMll fa; _ I 1 1 ' I � ' I � I $ _! , 4 _1I { { I I II1 1 I I I ; II ; ,1 IIIIII I-11 ! I , '. 1 , 1' i- I I ,I I... IIJI I I I ....I i 1 Hill 1 .l 1 ! I ` I I.... { I I I. I I 1 I I 11 ' I I ' i 11 1 , I I 1 � Fill " I " 1 I i I I } ; 11 .. I ! I I I I I I I I ( 1 I 1.--i I I I I I I ; - I I I_.. I 1 1. I I 1 1 �1 I I I.._ I I ., 1 III ' MTM RIPPEY BY JV Y• DATE CONSULTING ENGINEERS FOUGHT STEEL — RTU'S CHK BY DATE. 7650 S.W.Beveland St, Suite 100 �OBNO 19230 Tigard,Oregon 97223 SHEET SK4 OF Phone(503)443-3900 i 111f. 1l• 11 �. I i i I I I I ) I ( i r l I II I : � i r I 1 ; 1, i I � ' ' I I I -i I I i t l 1 1 1 I t I I I 1 :, I 1 1 ._. 1 .... , I ._ -1-1,--.i 1 II 1 1 I , ( I i ,. I : , I_.1 I .i 1 i 1 j 1 , 1 I 1 . , 1.... t 1: I I l l I I 1 1, 1 f 1 1 1 1 1 f I i I I 1 • 1 I 1 1 11 I 1 f 1 I I ATTACH N W I~AT4 F4k1 S'TI I I I : i 1 I � � , .O lOP1OF I 1 ! I I I 11 8IT1 � c ruIEM ,-- , I I i X S NG-DECOK WITH CLIPS PER DETAIL 11/SK3• 'i F I I ' CLIPS! •MAY I EION INT R'IOR OR *TENOR!SI E ' I iii , ! rli � I , L � ' , PST MEMBERS)! Q� :4 if i rt,, S ' I i I ' I 11 I I I � -OCAj CLIB ' I EQ R L : r S)iNG CiK PLANKS'SO AT THEY DQ NOT : iI I I 1 i 1 1 I 'I�-1 $ C Ci� P 1 K�1 li+lI" r1 � , � q ! r- 11, ,, i t I � 1 1 ,1 1 i i '• I 1 ( i , i iSl Q1Ii�l I , 1 I I 1 ! i , i I , 1 -I t 1 ... 1 1 1 i I I i.. [ I 1 1 i I i I I ; I.... , 1 1 I i i I ( 1 I f I � - � i i 1 i I f i I ! I I , i 1 i , � 1� .I •, i r 1 ...I i pp I I t 1 , i 1 ' 1 1 i I , I I , i I ; �1, , 1 ; —i , , I I I I- i i I i , ' I I. i 1 , I 1 t ,. 1.. 1 I � , I ' ! I i I L i. I I I I 1 , ,' 1 1 1 EXISTI I I I 1 1 I I ' i i 1._ 1 , 1. 1 I1 ' T-I I K iOO1F _ I , �._ L. I PL { 1 1 1 I I rh ' !1. I j � III ._.. I l'i i f i I i I 1 DE K 1I L1 : I ! , 1 I � I ( 11 ., � I 1 I ' � � I Er I$TIrG �"'--J 1 ! ' ; . !_ i- i i ' ' 1 NEW(PLATFORM I I I E WIDE , , I l i. I i I r E.RS PEIi!R N 1 ' ' I 1 i , I M� LANE 1 � � SLA • I r i ' I. I I I II I ,i l 1 1 , ..., I ,, I I �i I l j 1 CAM : I I I i , I � ,yi y..l t i l (....j I I 1 1 � , I I I I1 1 1 L... H„)...1.,..4.2, ELOIIW 1 I , ±1, 11j ; i ,--1• 1 •r , , t1• i ? Ifs jI I i , I i , ...i i.. I. L...., , I , f I I 1 t i I i ; : 1 ,, I : , , , , 1. I 1 . 5 I l I I 1 1: , I 1 , 1 I 1 1 11 , I I 1 i t I 'I I I : I I , 1 1 , I t � I f 1 ' i 1 I 1 y , I i I f. I I I I I 1 t 1 1 . . I , , , -,:t.----I .,. .. 1 — I , i i : i !t 1— I. t = t 1I 1 1 j ' i r I o 1 ' : I f 11 pR,KX 1 1 1 I 5��1N , , I i ; 1 ; f I ; '1! j 1 I _ 8t1'2PE RUN LONG SiDE PLATFORM ; I o1Ecoiv, L"fz. 1 BEAM PAST SNORT$ID ;REAM i < < I ' I i 'v . r '• 1;'9 , '�a AND ATTAbH WITH (;/) 111/41)( &'' ' ' ' 1 �`: ' 1 1 SINfPSQI�LS E /S S" I I 1 - /(' L E ,\; 1 1 O/C. i 1 , I , � �. , , i I I I I FX , 2a I i i r i , , I i j I 1 ;� 1 r 1 I r 1 I r r _:1, F i f : Q L � IAT CORM �� � 1 i I r �RM 1 E K ) I I � I ' 1 i.. ILL 1 , LIII , ! III i 1 1 1 i i 1 11 i 1 1 1 1 ! ! ! ! " ; , ! ! ! ; ; ; , 1 ; 11 I 1 1 I 1 I I : 1 F I I I I I I r1II 111 ; ' 1 1 I , , I 1 v i , ;_ I I ,...., � I I I I I � 1 1 I , 1 I • .1 ; I I 1 ' 1 I i. 1 I 1 � 1 , '_ 11 i I i 11 1r ; , L - ! ._1 r 1 I I , I i , I I I I i i 1 Jr ! '- i- 1 I i_..1, 1 1 1 1— ' I i 1 1 i I 1 1 1 I I f 1 , i I , ' I , .'. ! : I I I I1 L F I I ,! ) I I I 1 i 1�; �' TM RIPPEY JW .Yl CONSULTING ENGINEERS BY V V DATE FOUGHT STEEL - RTU'S CHK BY DATE 7650 S.W.Beveland St, Suite 100 19230 Tigard, Oregon 97223 JOB No Phone(503)443-3900 SHEET SK5 OF . - - • ;'''.--;--I' •;•• 1•• fri f; 1 I I I.; I ; III; Ii":1;•---N. I .IIIIIIIII " i ; -., 1; .,11 ,.....- • , • • , ; ; • 1 ;f !; 1'" ,fiI;;-Nl11 , .. ;.. I. ..I111 .11I- 1 Iiri frii ; IiiiiI- II •••11-• -• I ' l .„.. . .1 i• iIIII- III •11 . 1 •11 •1 ; 1 (. Yi111 : 11 ; 1 •11 ; ; ; ; ; • -1, - II , 11 -1 ; 11-111 .111 I ,• II, 11. 111 .11iIiiI •11.. 1;• 11 ; ;;;-;-1111II 111. . ...1 . . ••1 .1: ; : 11IiIIIL . -1..1 .[ .••••1•1 • 1 1 :1 H -LIIIII • 1• 1 •111 ! •;*1 .1;• •11111 ; 1 • 1 ; TI I LH H11 •11; I T. i, .1 I. 1..1 1 -; 1, .;:ii•-1 I 11' , k." • . ; .1 1: Hi I. I 'LI-. •-•1 -I .;•• 1 I I- 1 •'' 4.1-i IIIII 1 t'....;-.1 I . I ...I. I ; I I..-.11 i, I. 1-,. I I i 1 I ;,•••i- 1- I ; I 1 i'." ; k l• I I I ; 1 1 1 : 1-I I 1 i I 1 i • H• 1I 'I I I 1 "..1.- • .I. IA .; •; -.. , ; I li 1 1 !Hi 1 ; •I• 1 1 !I 1 i ii; i ' I I I; I I. ...1 4pr-1 I /I 1 1 I ; -1r il 11 i 1 I ;i 1 1-- i i I I .; ,1_,I -,.1,...,t 1 11.1..i.j. I ; • •• 1 1. 1,, 1; il; iIi• 1-1 1 1 'I, 11 -I l• 1- 1 i i 1 r; I ...1 .D.;,!4. 1 .1 •,• 1•••,• •i:::1-1::,-:z ,-.1 i .i...1 1. •• HI : 1 i, 1 1 1 L....A 1 ; -, z,. 1 , • i..,.....,.. i.,..,...z.•„.•••1 •,••,.• , •:, , ,: ., , ... ..„: :,..-; •, , 1•••• , , , , I 1 z, 1 1 1 .1, „, t..,,, ,„ , , ,.. ;•.,• •,• , „. ., „ „ ; , 1 iLi: ,- ,•• ::::• , . .. i , , , 11111 11 , , •.•zi:- 1: ::: I :, ,- , , • 1 i , . z z z - z : 11. 11.. i . ,•._1_, il•: •• , 1 z ...., j-i• ! , ' z i'-------'• .1.-:.,--- f i ; I• , .--,..- - ...! ,- ,,s,.- 1.: it,i •,,..:,..(58.0;•E14,4) 1- t- :;:-1 i •--I..iz 1: - i ! i ! 1 1 I I-II- . . .-- • , - I 'I ; 1,-:i i( )11\1. ,...$) ,,.1 I. ; crti Hzi.:: •'z i• i• 1 i 'LI' ,,.- -.1 1,„,-,,,-.'1..ilv i. ii, 1 1!: i •, 1 1 I 1 , , :„ 1 1.- ,. , ;,-.:::: - -.1, •I, i i 1 i 1 i , i Li ',..1 i 1 ,,,% 40..,* ...:11,tei ,i.l. it“,i'Lt-iz-Ii.51 1 i H• 1 - i -.1:.1 .,,.i.:.,1 . Li 1 1 I 1, . W :1---••••• •-....!--• -1 1 i i ,, ,• 1 i• 1---iwtz,,00. = 1 11,10. i LI..z• l' 1 1 1 i: '••••L.-r. 1 -I 1, w 1,-.1 , -, •:-• - ! • -it i 1 1 : i il I '....1....:L•r:1 I 11,,,,x4- Hearth). l•-•1 iciAlr'c, ' 1 ;::;-1-•11 -:-::LI 1 1 "H; •';. !••• l' ; • I • - • 1; I I H• 1 I ; 1 I i i : • 1,• L., 1 ;1‘ l: 1,,,1; 1 1,1-.16 •1- :. t : :1 i. ; i• '..-•: , i 1 1. I. 1 w i 'i -1- , -4-1-- --I ; ; 1. .1-1--:;;; • II ' " 1 -1 i . i ;.. 1.,', •1 1...1 ..i . -77;-,9;;•7.••si9 1%1-4 •i'ai•-••••,•11.1-... ••••; 1" 1 i :i...1. .1..1•••!..•1 . I, - 1 ; 1 1;•;1 -LI ::::1--1-•;1-;•1::::- : • -:!--4?Net . :- -i •i• i .1 i ': 1 1 :; I. I : •".••••• :: i ; , •1, :::::: •:;;;;-- i •;;;; 1 • i 1 ; I .1 A...1. 1...i.: i....i .1, 1 •i•.1 ------,•,,„,....\\ •1 1 i. 1 : ::;••:.;•• •••;• 1-• /44 _. ,,- ••••;:._-;,0: 1 T I :, I : i i • i• i -;.: I. .1 . 1 .:.• ; ; ; ::- 1 •H• •1, -II: i • '1. ; ; ; I. 1.....L...1. i...; 1 1•1•••••1 I ; T.-..1.. .1 . F. 1. ...; ki:4\,7.7;_,..--- !.7 ;.,....,--- ,.„--;,. • 'LH :, 1 : ; : ; H.,•. .,. i .1. 1 1 1 1 ;1 , ,,,- ;,•-; - i • ::: 1.- ;,--1 -Li-1 1 .1J .1H .1. .L. t .1 1....;••••1 • 1 • 1• I: I :.011474v-r; 1. I 1- :4, ;:f.--7.';•,,.; ;:-.1. I- :, - ; ::, ; 1 i . I. .:1 1..I. i• 1 , I 1, h( 50.:4 11):, I ; ,-; I ;• 1..1. .I, ; ... ; ..i,. 1 I . 1. v1.•••!.. i l• 1: 1:0---,•,,,,:l I ivaira 'f--',.; z;:•• ;,- •L',.• ; i 1-t l 1 (1)'.NI •vii 1 Co 1 tPf41 I i I 1-i- 1' ', H i i. ',. 1..1 i 1. 1 1 1. 1. :•••••1; i (1? , I 1. 1-1. -1; 1 1 ;1• :/; ::' ', ,;j„"s1?-6 1 i 1-1- •,, t ,Th 1, i -i(iiiti, '1. 1816'1 t 1 1 !---!;;:•1:- I 1 -1 • 1:1-1 1-1 1 1 1. -, : • : • ; , .1. ;;; 1•.; .1; 1 i i I I ! -1 Hz tAP4cr-TT , °9*? 1 ;-)P1 .-1 1-1 tr, -LI" Ii-i. ti;-•;• 13%,11"I i ';,..40'-'• tkItAt I I. I 1 I I I I I-;;;{ ;I • I I - I ...!, .1.... "......1.1.......; ;.,,,IrdoL,,,,,t,.;-- ;;•-•••;-;•,,Ap7 I'i,k,, . I ; .1 1 I, H i i 1 ir• 17 r“ : :. . .i-- •ii••, ii , 111 , 1 , .. .i . i.. .,....,; ! . 1• 1 1 I . 1. ';. H. W ) L.- i-w :. 1, 1 1; ! i ; I 1 1- i .i• 111, '41 ; !. I ;.•;. 1 :4, I i 1 1. ; ! •1 •1-- 1-• , i•-;;;;;;;....4 Arlit*v.: ::- 1 i 1 i I 1 I .: ; ; -; 1. ; ; :- .;&) 4.- ;:c.w; ;i': I i/0,0. - I liwto ;./0,90. : 1 ; ; , 11J „., ,..... 1.. , ..! , :;-•;;„.._. i. , 1 :; ; : ii 1-", 1 ( )(.8,)1' ..s". It! ; , , • 1 ; • : 1 ; •:• - i i ! 1 : I . H ; : i ; ; - ; , •:: ; ; i I f-, : : , -,--, , : I , 1.- 1 ;•• I 1. 1 L.; •;. .••• - : ; , : - . ,,,,.• i,,..., I ; , ; , , ; 1 ; •::. .1 , eXpIt 0,/s 9/or- "1- ••J.-; •i I ILI IT; ;II ; IIIII IIII,.. 1 ..1IitIt.- III: H- 11111U • ; a 1. , , Ii i. i ....,...... .:.; ,.. . ;,.. I "I'•••i ' (1) :•-) 1-.1(Prii•11 li'l 6, jle' ll 7 1 . u..19..11'1•1. 1 1 1 1 1 I i 1 1, 11-1 '11.11.. 1 .1 !; :i H. lad ::::::::; : :, !• 11 , HI ,.. .i : ; ;;. • 1, ; , :. ,• ; , •:-. 1••; -; : l 1; ; ; ; ;: ii : i •11 , I ;Hi , ; LI li...; •;.. . •••1•• ••••• •••;- ;• ;•••,; 111H , 11 .... ;. 1.. . Hii. li.. ;• ; ;;;• ;• ;-•;, ":„ : 1 , 11H11111. 11 1, ; ..ii •• ;• : • ,: iii , , : •; ;, ; ,- ; , : ; „ ; ;; 1 ;• ; ;; ;. ,„,"iii-ilpiAirf-virAAlijjr;..f-Hiiii ., -1 1- ; i 1 1, 1 1 _!. • • I 1, - i 1- ',.. 1 1: 6.,r.,„1 •;„„,,' 1 •':•• 1 luidt=i.s.„ i,,,,, 1,.,1 ee'tft-I IT•!. 1Y,. , -Iii,. ; ,.• 1 . ! ! •, 1 ! 111 I I- ii -., jry,,,y-1-„. r 1 1 „ , . -„, ; 1 i• i ,, i ,. .! .,...., 1, I: , 1., •li,)vkt,j- 11,4 'eA/,, ,s 1 I ;:.-" ; ;• I ; ; 1 ; :i . ..1.. 1. 1 ;. ; 1 ; , • ‘;' " :1 ;' I 1-iti., ;-\tpigEgs ITHArisfm.443F-Pla, •-; :.: 0 • 1 !• 1 ,- .1; 1 : •„ 1„,h,.,,A44- •, ;...„10, hi -• i: 1 :-••••; 11 ; ; ; ; „ ; ;; ; H : 11. ; ; I •; .;.•••11 ; •;:• ; ; ;„ ; ; :•: :: 11 -.! 1: I : • • 1. 1 •• ; :; :.-1 ; •:i tv:t •:: • . -(;,)&..04r:••Vx‘ 4`i -1 1 ,.. LI i. ,.. i , 1....:. : : : :. :. : • '; ,•;1: 1.-; • ; ',: 1 : i i ;,: i ;;;.1t474 : $.pAiq •::.• i 11-,ti; 7, 1 ) : )c;w,s-ar• ;••• ,••••„-;•;-;•1:•:;:;;;;;;:.; H • , ; , : ; • „,... ;L. ; „..: ; ., . , •. : ;,.. , , 1 :, :. --:,4•;-:: i '::: ; ; •:. ; .1 1 •;. 1 1. 1. i i I 1 k; 1;,; • 1-'' '; sitt„ .106 4.1, ; ; 1 I ;. ; , ; I7; t3"- 1 i !cli !•••"1" • ! '" 1 ; 1 I I "....IW I . I. ,,,,1 1/413,9 -./ . i • ! •^" ,, 9r •,--) r : r, 1 l' ;-; ::: ; I ; ; f. ; J. I , ; : •••,••„: .• • :: 1 ; i ; : ; ; 1 arr;„ ; - 7.;;;zZ 1 1 I ; : : ••:, •-• ,••••;: ::: • •••.-: I i .;..., . , : itz;, ::: : ; •,.. I. •:, 1, 1 :--;;• ir,••••4- •••; ' ; ', ; •:- : :••1 ---;- I • i , 1 : ,1 : • 1 ••• . ! 1. ' 4 ,.i .- 1••F81,;:it 11 „ , , i , , , z• z. , 1 , z -,-:, :•• , : z1 „ i " ..-e4,. 1-. -st' vfi *.„14' .'t-i. 1 • rt 1 ., "" 1 , , i ; z1 , , z11 , , .z. , l, i i . i 1 , • z: J: ': i, .i i i ,,bt. ..,. , ',.$1 1 ! 1 -Pt; I I 'lIr I i; 1 I. ."... I , , I , , I , -, .,.. ; .1 ; "...; ;. ; !, ••• I "• .- •; ; , , " ! , "r.,.. !..; !.. ; ." " !. ' I I ' !, : ! : I ;"• 1 i I ' ;• 1 I .1 - I , v I I ; _l__._I_Ljei4 1_,t1,_•7<,...; ".. • 1 1 :. ." I. I 1,..,' •••' ;"I I; " 1 I ; "..!....I,,,..; I,"; I (.,'„,I ,I ,,"Ad: f(to•t;,I I•itn.1)",••• •"I ; I I1„..,„;,,,• ...,,I ; I I i ILL_____ ,-1-1-,-, 'i ' ' -, I; 1 ••• ' I.- I• I- I• ici„.,„,• I .•,,,-IFOft..1;;CALfiE ) .".z, .771- " I "r";1 1 • ; ;• - ;;; IS :• ; ,-•; ;, 1 ; ; :, 1 : ; ! H ; , ! H. .....;:•:.-•! 1 i, , , !. 1 ; 1 ..,-,---• : • : , ; ; Il I I •• I I ; ; I.: ; ,„' • --le,,ii 2 .;: :ge),. 7.1411 , I I ; 1 ; ; i ;••• :• :: 1 1 - --III--':-;--;-4---.---:----- -t—t:; ;:-74,: ; . 11 - i ,. IIII" Pifii7' 1.flift•-• ••-• Gt• ;I; i •III : ii ,; ; ; I i ;. ; .1 H.71‘;;; ;,t ! •.;." 1 :-..i' l l .;ri ; I I ; ; i - I1 i I I.- -iz • -i.ipki Q!". ..e „,e_Lt,,p. e. •44, w:e,jp4- ft) 1 :•. i ; • ;: : :•• --„--rrs7 1 P .... -, .! , 1 1 .:, 1 ,.. ., •. i lict,,,,,g, :. 1-T' 0- • • ; • ! : ; ; ;••„• •••••••• ••:-::•: !• ;• ; ir;-, •; ', - 11 ; .• ; : ;, HI : Ii. 1 ..: 1 ; •••• •;, • ;, ,• ; ; ; •• •• ;• ;: ;, , , ,, : . ; •11 , .., 1 -. i : ; i :-.p.:: ;••• •• !. ; i..- 1 E. ; .; 1 . ;: 1 ; ;i i 1 , i ;-r. ;mr,Aj. !-1).,..to,...i .t,,riA.7.0;‘,./. I I. . ; : I. : : 1 ; • ; :• :: ; : :••• • i ; : ; ,.. ; ..,.;., . 1 : i ;. 1 ,. .1 • •;.• ;• i •-• ; - „ i: „: i ;,::; • . trt ••• ! ! ':• !• '..• -. '•• ',. ,.- ! ; •••-f : i ! ! 1 : I i : 1 ! i i !.• 1 " ! ! ,i1 t_L44,17,4, ,Kiy. , ;Ala- ..,s.,orPoref,tu , H I , •I ---:- i ! ! ! i ! ! •i ' - -4- :--',----1----' :-; -' --•,---; - ,••••-0517-854,4-1-•-•-•-t-- .5174.0 i '::1 Ti •• -i- ; :• ; • :i•-:-;:-1 ; • I : ; , ::, ; , , ; ; • : - -- : i -; ' :: ;. IPt.v..c.'laa ': 1: :: I: ! ; '• ! 1 ' • .. . •,;;_•:1 ; .1:, 1••.........,; 11:,,,•; : t-,,eff,,,- ; : c,,,.11; 1 •• As; st .(zIat41(.0 ••••••; . i , , ; :. ....., •• ; ; 1 ,- i, ; i ...; , i, 1 : 1 ....; , ; 1 1.‘ ,.pA:-... tio :0N, :. rtiov-;./-7- ,•••.--r-i.-1--••-.• IT-, i : ,A),;,,,t94‘ ; ; - i : I ; ; ...r, :. ; • 1 ; ; ; ;• ; ; ; ; ; ; ; I : 1- ;; ; ;•• :,• ;•-•; : 1 ; ; ;- - ; 1 : 1 - 1 ; 1 ,-1 : 1 - ; ; : ; • v.,- : I :: 1 1‘ : ; -. ; i i , •••••I ;•••;. i : ;:. :• ••• ;-/: : ft.,/, , : :, ;,. ,..,1„,,,,,, •„,:., 140.3!rsLi : , : • ,••1 (7.).011 its-•yt••1 .: : ill-iv; ri,,,..,;,- ; , I ; 1 : :• 1 : ; 1 1 i. i :. 'A ! • I • I I • I , 11 i -:. 1 ; ' . Hi ; ; ! ! ; '••II• 1•• III : Hi . I ; II. I. ' ! •1 i, I ; i. I I- '• I I• I • I ; II : I " I •'..I ...I. ! ftI !;; I; le.3-; *'• 1 I•• I- " I• •" - I ' I . ; -; . , ; 1 , 1 1 .r-7,,-;;;-•!.. "..!;;,---;-1 i 1 -; I; -I !... 1 : I • :- .! ; i ! 1 It-i-- , 1 - 1 ! I : : I : ', I -I • ; •:- 1 : •i " •••; ; , I , I: ; I 11, z' 14.14,1,, . ; ; - •; 1 ' ••, "•Ii • 4 1 , -it- i , I . ;: .:, 1 i. 1 i tv;;;,.. • ".D,•igk pocip,:;4‘,. 1 , ii E,..) lt:. ; - I-7 It, :, 1 : i li I ; Iii 1 ; 1 ; 11 : :,-.7-1 ;•• •, :;• ; : ; ; ;- •;" ;- ; „: 1 , ;; ; : ; „ ;• , ; I „ ;: i. :„,..;..1 1 I, ,, ;_; : ; :. •• i : ..; 't.. ! 11;)PloF efitkodvv‘i .., ... . , . • i '..-R ! '.• I ' I I. I " I, ; I Igz IR •• I-1 III,• I I Ifroi,(,tbe,....IPtRe0- rccAt4;;Frcit. I 917 g`IrtIpit i ) 1 .. ! . ;. ; " - • ;„; ; I ; ; ; ; ; 111 ! ; i. ", "•; ; ; " ! ; ; ; ' , " " i ; ; . , I II• I".•!I I.; I * • I I I • ; ; I •• •• ' • I ; ; I I I- I k, to ( ) 1NS I 46.v.htxr-oN 1 • . , . i IL-c)Ab, r-S'• isT'AAPA. •; •- • ; ; ; ; ; 1 ; ; II ; liS k1 : 111 : I .. I.. ; •••••• ;, 1 : ; 1 ; 1 -, ; 1 ;: lii., ;,. ., ;, ; ; II , .. ; ; ; ; ; 67310-,0 I . •.., ...;...... ....• • I, I !•• II 1 tAattorft,; iiA.i..; F 4. 36;•1,4, i (a0v...i., F-4 ISI1C4t4,•StIO ;, ; •1_,...,... i ; L!-, Li 'CI 11 ; I ;'. I ; I i• • ;•• .;•• ;• -• ;- ; i ;• 1 I I ; ••• 'I' 71 3I • I ; ; I I I I I I I I ; II IFL4'• ' • . ;....l...;•• ; •.• : ; • 1 • ; ; ; • 1 ; 1 • • • ev `3/4 DATE . TM RIPPEY lelLii 1 . CONSULTING ENGINEERS firt46-t4r 5Tti,l, AnA CHK BY DATE tosNo I 7650 S.W.Beveland St,Suite 100 /Z0 C-A OF Tigard,Oregon 97223 Phone(503) 443-3900 SHEET • 1...•.; ! 1 1: 1 '1'.-7.1 "I-1' Li 1 I 1 '1' 1. i. i''''1'.....'"•"'-' ,.1.• I i..i. 1.- l'.11...1 d .'I'''''j' .1 .i.'1 i-1 1' j 1'''''i'..-•:•:'-1. .' i I 1 :...1 I. .; LI"_ i 11-1.-11. •1[1- LI I LI-•-•,1-••I - -1 1 11 I, j; .i 1 , ).1 IR I• I 1, I •I 1.-.1.1.--1 I 1 I I ' I. Ii J!' 11 , .1 •-•.!---I . 11 .11. .1 I. 1 I I 1...--.I 1....! .I.....1...., ; I 1 1 1 1".1...11..I1 .i. .I I 1II I. .1, .1 1 1 I• I .I 1 I 'I' il-1 I I ; • ...1 • L....I!: j i..!...:1-. I .I I 1 i•-•-:11 1I 1.........I„....... . .1. j 1 1 1 .1 !...; .;...1. - I ' ; . 1 1 i 1 LI .1. 1. .1 I. . . ; . I,. 1.... . .! ; .; •;. 1......; ;. i. 1. 1 . : I...I .1,... 1 .', -.1 I ;... . 1..... ,,, -;,. , 11. ! ; ; ; ;..'i 1 1.,.1 1 1 .1 .1.. ; .1...1 .1 1 1. I 1 i i. I. I....1. 1 f. I 1. 1. / 1 1 I 1 1 . ...I .1.... 1 1 - 1. .1. 1..1.... ••1 1 -1 .1 1 II I • ...1...1.. 1.. 1. i 1 1.....1..1..1.. ; i..1.....1 •1 i .1. ! ! •-; .1 ! I H .1...i....1 .1 I i• Li •i ',. 11 i ! ,.. 1 ! ,...i. .1 1 1 1 1 j 1 i. 1...!, ; 1 1 j •!..i I 1 i 1 i .j. I .I - .1.. ; , ... •! 1, i 1 .1- i tAiir..r.1. .11) ,tkits i.....1. , .. 1 1••1 .1 i 1.. .1 I i 1 i-1. ;•••• ••' •[. .1 .j .1. LI. i . !. .j. 1,. _L.; 1. 1 1 I. ! 1 .i... 1, 1 1 j !, 1 1 1 ,j !.....i .fi ..;:. i 1 !.. ! i, i. 1 11 !.. 1...1 .1. i i 1 .1 1. .1...!...!...i. 1.. - .1 1. ;.. 1 i i 4 • " i, .4..1... ..1...1...1. 1.-1 .1. 1 1...I...• 1 .1-.1. I i 1 .!- i i i j 1 .1 i.. . . i .i.. i .i, LI ,H .. i...j...i. t .1 I ; 1 Li 1 .! T. I 1 ,, 1 ! .1. 1 l• I. 4v ; 1....!...i 1. .1. ; ,---.;•••i...,.., •. ; '' J ; I ;...i • •••1-1 ., • 1 I •I • 1.:•I•.1 '1, 1 I • ;.•1.-'••••••; .•;... ,t-ts! i•+tsr I o(/ .(tAreAti-', t-aAlizsrik,- jrkseo0 1 01',J41.1 i I I 1 I t -I:-111. I. • ... I. • I "1 .1 1'i'-'1.• i 1 11 l' . I. i' .1..11.1 i , I ; '". I ..'i .!-I-H•-• ' !.1 '''''''' ' --.1-1.1. I I I'fi'.rt° 6‘41s14q*s •)•I'' LI .i.' '' i'....: fii....I-11-.1.....1 1 1 i• i IT'1'1' -LI ' I' i I I•!..1.44..).(..:,.-.-............ . . ".....---.1--......".:11 1 i.-1„..i...I„.'1- i1 ; 111 ; 1 ; - " . ' 1 11 ; 111 ' 1' 1 ; 1 , 111 ; H •; ; " ; ' ', ,' 1 , 1 11 ., ". •!,-,' , Ii ; .•, 11 ; 11 1. 1 I 1 1 •;' j.' 1 • I' I' i I •,,-,"1.•I •1 '1 ' 1-1 1 . ""1"I i-•*I 1 1 *t,P;screraf) 1 Pv ;lc. , -PA• 1 .1 tr,, .. i&T), 0-; ••••• ---;••; .i '', ; i I 1 1 1 ..;,. I .1 .;••••;',....1..•.; 1, H; i''''F'.1---;-; I. 1.. . ' I . 1.................1..i.li i ; I 1 •I 1 1 1.......I...1.4 l •1 •.1. I• 1.4.--",....;•••••1 1 1 J, 1..1 i ...1...1. I I ",.._I... ..I. l... 1 I. 1 i ' 1 ,...I .;..1...1 ; 1... 1-.;.. I. ;. , V.9) . vic ..15...1./l'i•P.1 I 1 1 1 ! I .1...i I••i.• . - I, . 1 ; ! -1 .1 ._ i:.•1.. i 1 !. I1._ 1.•-•.. I .i. 1 ; 1 i.•••,•••;.J. •:. I. i ! '!....L....i..1 ,,.1 ,1 „1 ,,,,„H. ! .1cAti,4 i. ! I - •', ! ii.• 1 ••••!•••.. ; _ 11.••11 .1 i.. i. i I .; ' H. I. 1.A .1; ?.,. :(Z/i/V11 1 1 1 1 I . . . ; 11...11. I 1 1 I. 1 : 1 1 1 i I 1 . AI 1 1 • i. 1 1 1 i I 1 :. 1 1 - 1..i .1.. .. .1....1...,. 1 . 1111111 1- 1- . 1-1 -11 111. .1...,...1 . 1111i1. .11„IiH .1111..1 J..1 ...1 .. ITP. ir-.T., ; ..1-13......1 17- . . , ;•• •-• , i 1 ;..i..i......i. I i.. I. j .„".. I . ; 1 ,. .;. 1 ; ;. . ; 1 I it. 1..1.. i....1 1 1 , •1 _LI .....1. 1 ; , 1 ; i , ; I '; L''''' .. 11 ! ..i.. ....I... l.. ; . ',.. LI ...i. l' !, 1 •• 1 I. ; i... 1 I. I AS..t..A'A".E.....•A*/0 x 0,- .. , Cirr.:r.;...4,$ i I' 1 i" 1 I 1..'..."-•:-.*1 i...i. • i • •-!...1, , 1-• i..1 . . i 11 . 1 LI i 1 i 1 !ij. 1. . 1, •! ...! : .L1 '.. 1 . lir 11. ...; • .' 'L-1 .. .! • - ...'.. ,! ''..-1 .1-- I -I. .. -1 . 1 l••••i .'••• I...-1- I W..Z Q1.014::,%,-.)(4") (1.;;;'44.1;;;:11- 1.)-1 i,S(kli 1 4;1 VP.)!MtV... I1 ; . ; 1.. 1 1 " 1'.. 1 --) ,ii i. l .i . . ,,.. i. • •1 . 1\: • i..11. 1 .-1. 1 p.*.e .t . . (...1r.4t.,..Js...€,I.-....ciiklIi14,6„i,,,41 1... 1 ii I. Li . i. 1 i. •i. i1 I i i i 1 .„.. i 1 • i i ,... ! . .....1 .1 i i. I 1-- 1 1 ; .1 1 1 1 ; ' 1 .1 ;, 1 ; 1 1 ;„.1 ,1.„ 1....1..1 : 1 1 1 TTV:r4r"r74\Pic ; 1 1 ii .,... • ...; : 1 1..1 .1. i. ii . ', I . . I . . 1 ! ; ; ; 1 :. •, -,. .-,, -,.. iii , HilliIii 11H- I iii- 1 ;.- 1 , . , , ; , , , , , , , , • , , : , .. , :. :. , :: , . : . : : !-i ;•• , -: . . , : , ., , i .-.- • , 1 . , , ! .: , ;1 . , •• •••, . • ' ! t• • •:-.: !•••,.- I 1 • ' I , v ! I ' • ! '• LL ' ;riy; &E.,4iinj ';Vs:, 1 P_.....;‘c. :StRiiiii'itiplZ '-; 1 I i; ." I : ; '; ..; 1... . .... 1 . 1 ; ... .: .i.. i...1 ' .1 ; ; 1 : 1 1 1. 1 ;. ; -i Er-,,, ....; ,.. ; ... . .; 17......,[ il . ., ....; ; 11 ; .;;..•, 1E, E. . : • ; : ; ; ,;'. ;• '.•• ; ; 1 • ---; .; • ; i : ; 1; i 1 ',; • ! .-- -1; '•• E• 'Aii%4e,i'A !f:4,itT-Er4M'.-H ; isi) . ',1 '' ' • '• '; ': I '•• - ' ; - , • - ••-E:. ;• : • - ; ; E. E i, , ;:-• 1 •••E, :E. - I • •i - . , : , ;E, , ;z11 ; 1 •A 3• ; ct.f-;;AIE I f rtr•PvE;0A.it;FtAA4) ! ;••• i E : 1 • ; -- E; " ;•••; ; 1: -; E ; ; E I E••'•-• ;,• ! •. : i ; ; ; ; i. VA iti E..; ;:. ; -; • • ;• ,...E. • i E.. H. i. i ; E 1 . „..i . .., :: 1 ,.. ; E,.. ..E. ;„..:,.„ ;.. ;• E .E E:, ; :•. ! , .....E,..:. 1. ; - 1 96'$' ! ••• ; --- , 1 • ' !•• ! :‘• :. i ', i ; . 1 ....! ! ,. ., : ; , ; : 1 i ..,- , .. 1 i i :. 1 . A . 1 „. 1 ! ; i.. „. 1 . 1 . ! ; . 1 . ,...1 ;, ; - 1 ; • ii..1 ; , , ;... , ., , : ; , ! : , ., ". 1. . , ; , ; ": "; ; , ; iw," 1 ,., 1 ;.. ,. (%4b; /0•Aik icApi,c7-c :CAPAci:4-.1 1 • ; i :..1 I , ; ; ; ; ; I '; i . ..i - ••• . I ; ; -,'- : fetlE; .1.".3w 1 (9) ct,.e.,b_s• ..',o 0:i . ,_ ., ' ' ' . " ' ' '.. i I ' ' -• ' i ' i '---- -- -------F 1 ', ; ' , ! i •, -, 1 ---- -E--T :-.-1-- -r--1 : ; 11 : . 1 ; ; • 11 , 1 ; 1 -11 1 .1. . . - . 11 ; ;; / 1 ; . ' ' : • -1 '- ' 1 . ; : 1 ; • : : 1 ; ; 1 : ; ; . ;• ;' 1 : . ; ; . : : 1 ; - • •1 -: . ; ; . I I ,.. .1 1 ; I 1,1 ";-: 1,-. 1..:i , ;: ,.. I ; ; . • . ; 11 1 . ; '1,.; ' , H, 1 ; ; 1 11 • ;. .:. 11 ; ... .., .; .. ;;.. H.• 1 ; - ;. ; ,..1, „ ..,.1 .. . 1. 1 1 . ; .1 . . ; „ . . ; 1 . .; ; .; ; ':, .1 .1 : 1 .. ;;. i . .1. ; . 11... 11L. 1 ;. , 11 ; „ ,: .. , • ; . 1 1 ' ' 1 ;'• '' '..'• ' ' '; ; 1 1 1'•1 ': '-'i -.; ...i ; ;. • 1 . 1 ;- 1 ; ' 1 .. . . '1 '1 ;:;;;;1-- ; 1 ; 1 1 . 1 1 1 ..1 1 '.. 1 . .. 1. 1 1..... .1... ..".. ; . ; 1 ;. ; . .1. 1..1 . . .1 ..,1 1;.. ..1 1 1 1 1 1 1 - 1 1.•1 . 1 . : 1I I ! i 1 i .1... . .. j .', 1 i 1 i 1 L 1 i I 1 1 1 1 1 ; . ; i. ; ... ..i • , .. I - :. : i , : . , , • • • • , . . , : : I . ; , i ; . .. ./..1M?\.. 'IM RIPPEY BYZ-7) DATE CONSULTING ENGINEERS _FCLA 6-1w IVELS_Lg _ CHK BY DATE - 7650 S.W.Beveland St,Suite 100 JOB NO 19 az0 Tigard,Oregon 97223 Phone(503)443-3900 sHEETC,Q. oF Title Block Line 1 Project Title: . You can change this area Engineer: using the"Settings"menu item Project ID: Project Descr: , and then using the Printing& Title Block"selection. Printed' 8 JUL 2019, 4:53PM. Title Block line 6 File:=N2019 Prolecls119230 Wilametle ItVAC Fought Steel RTU`stSTRUCTUNAL1CALCSt19230. 8 Vhf 00 Beam Software copyright ENERCALC,INC.1983.2018;Build 1018.12.13... Licensee:TM RIPPEY CONSULTING ENGINEERS Lic.#:KW-06002562 • Description: Main Header CODE REFERENCES Calculations per NDS 2012, IBC 2012,CBC 2013,ASCE 7-10 Load Combination Set:ASCE 7-16 Material Properties Analysis Method: Allowable Stress Design Fb+ 850 psi E:Modulus of Elasticity Fb- 850 psi Ebend-xx 1300 ksi Load Combination ASCE 7-16 Fc-Pril 1300 psi Eminbend-xx 470 ksi Wood Species : Hem Fir Fc-Perp 405 psi 105 psi Wood Grade :No.2 Ft 525 psi Density 26.84pcf Beam Bracing : Beam is Fully Braced against lateral-torsional buckling D 0.1 • ICOM' 0.863 o y 4x10 Span= 11.330 ft Applied Loads _ Service loads entered.Load Factors will be applied for calculations. Uniform Load: D=0.0250, S=0,0630, Tributary Width=1.0 ft Uniform Load: D=0.10 Rift,Extent=2.0->>9.330 ft, Tributary Width=1.0 ft Design OK DESIGN SUMMARY 0.722 1 Maximum Shear Stress Ratio = 0.268 : 1 Section Maximum Bending Stress Ratio = Section Section used for this spanused for this span 4x10 4x10 fb:Actual = 677.20 psi Iv:Actual = 37.04 psi137.00 psi FB:Allowable 938.40 psi Fv:Allowable = of +p+S+H Load Combination +D+S+H Location of maximum Combmaaxximmum on span - 5.665ft Location of maximum on span = 10.586 ft Span#where maximum occurs = Span#1 Span It _where maximum occurs Span#1 Maximum Deflection Max Downward Transient Deflection 0.082 In Ratio= 1649>=360 Max Upward Transient Deflection 0.000 in Ratio= 0<360 Max Downward Total Deflection 0.227 in Ratio= 599>=180 Max Upward Total Deflection 0.000 in Ratio= 0<180 Maximum Forces&Stresses for Load Combinations ,T1entvalues Shear Values Load Combination Max Stress Ratios Segment Length Span# M V Cd C FN C i Cr C m C t C L M lb Ph V lv F`v +p 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.591 0.210 0.90 1.200 0.80 1.00 1.00 1.00 1,00 1,81 434.15 730.40Q 0.00 0.49 20.00.68 100.00 .00 • +D+L+H 1.200 0.80 1.00 1.00 1.00 1.00 Length=11.330 ft 1 0.532 0,189 1.00 1.200 0.80 1.00 1.00 1.00 1.00 1.81 434.15 816.00 0.49 22.68 120.00 404.14i 1.200 0.80 1.00 1.00 1,00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.426 0,151 1.25 1,200 0.80 1.00 1.00 1,00 1,00 1,81 434.15 1020.00 0.49 22.68 150.00 +0+S+1-1 1,200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.722 0.268 1,15 1.200 0.80 1.00 1.00 1.00 1.00 2.82 677.20 938.40 0,80 37.04 138,00 .,.0+0.750Lr+0.750L+H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.426 0.151 1,25 1.200 0.80 1.00 1.00 1.00 1.00 1.81 434.15 1020.00 0.49 22.68 0 00 0.00 0 68 150.00 0.00 +D+0.750L+0,7505+H 1.200 0.80 1.00 1.00 1.00 1.00 Title Block tine 1 Project Title: You can change this area Engineer: using the"Settings"menu item Project ID: and then using the°Printing& Project Descr: Title Block"selection. Title BlockLine 6 i P d B Printed: 8 JUL 2019 4 53PM Fite F12019 Prolects119230 wiliamette HVAC=F ht Steel RTU's1STRUCTURALICALC8119230.6e5. r Wooeam ; Software copyright ENERCALC.'INC.:1953-2018,BaiId:10.381293. Lie.#:KW-06002562 Licensee:TM RIPPEY CONSULTING ENGINEERS Description: Main Header Load Combination Max Stress Ratios Moment Values Shear Values Segment Length Span# M V Cd CEN Ci Cr Cm C t C L M fb Pb V fv F'v Length=11.330 ft 1 0.657 0.242 1.15 1.200 0.80 1.00 1.00 1.00 1.00 2.56 616.44 938.40 0.72 33,45 138.00 +D+0.60W41 1,200 0,80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0,00 Length=11.330 ft 1 0.333 0.118 1.60 1.200 0.80 1.00 1.00 1.00 1.00 1.81 434.15 1305.60 0.49 22.68 192.00 +0+0,7501r+0.450W+H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.333 0.118 1.60 1.200 0,80 1.00 1.00 1.00 1.00 1.81 434.15 1305.60 0.49 22.68 192,00 +D+0.7505+0.450W+11 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.472 0.174 1.60 1.200 0.80 1.00 1.00 1.00 1.00 2.56 616,44 1305.60 0.72 33.45 192.00 +0.600+0.60W+0.60H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0,00 0.00 Length=11.330 ft 1 0.200 0.071 1.60 1.200 0.80 1.00 1.00 1.00 1.00 1.08 260.49 1305.60 0.29 13,61 192.00 +0+0.70E+0.60H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.333 0.118 1.60 1.200 0.80 1.00 1.00 1.00 1,00 1.81 434.15 1305.60 0,49 22,68 192.00 -O.0.750L+0.750S+0.5250E+H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.472 0.174 1.60 1.200 0.80 1.00 1.00 1.00 1.00 2.56 616.44 1305.60 0,72 33.45 192.00 +0.60D+0.70E+H 1.200 0.80 1.00 1.00 1.00 1.00 0.00 0.00 0.00 0.00 Length=11.330 ft 1 0.200 0.071 1.60 1.200 0.80 1.00 1.00 1.00 1.00 1.08 260.49 1305,60 0.29 13.61 192.00 Overall Maximum Deflections • .... Load Combination Span Max.""Dell Location in Span Load Combination Max."+"Den Location in Span +D+S+H 1 0.2268 5.706 0,0000 0.000 Vertical:Reactions Support notation:Far left is#1 Values in KIPS Load Combination Support 1 Support 2 Overall MAXimum 0.865 0.865 _ Overall MINimum 0,357 0.357 +D41 0.508 0.508 +0-1L+H 0.508 0.508 +D+Lr-'H 0.508 0.508 +4J+S+Fi 0.865 0.865 +0+0.750Lr+0.750L+1-1 0.508 0.508 +D+0.750L-+0.750S+H 0.776 0.776 +D+0.60W+H 0.508 0.508 +0+0.750Lr+0.450W+H 0.508 0.508 +D+0.7505+0.450W+1-1 -0.776 0.776 +0.600+0.60W-+0.60H 0.305 0.305 +D+0.70E+0.60H 0.508 0.508 +0+0.750L+0.7505+0.5250E41 0.776 0.776 +0.600+0.70E+H 0.305 0.305 D Only 0.508 0.508 Lr Only L Only S Only 0.357 0.357 W Only E Only H Only Wind and Seismic Loads on Mechanical Unit Worksheet Calculates the wind and seismic forces for a rooftop mounted mechanical unit based on the ASCE 7-10. Hold down forces are calculated based on 0.6D+ (0.6W or 0.7E) load cases. . Wind and Seismic Loads on Mechanical Unit _ Windspeed := 120mph Exposure "B" Vasd:_ "no" (Is wind speed ASD?) Seismic Parameters SDS:_ .720 ap:= 2.5 6.0 IE••= 1.0 Building Dimensions Category:= "II" Root' Elevation:= 20ft Building_Width:= 100ft Building_Depth:= 47ft Mechanical Unit Dimensions Displacement:= "Fan Unit" ',9.,T Unit Weight:= 13921b UnitHeight:= 50in _ Width:= 60in Length:= 88in _ Curb:= 14in Curb Width:= 52in (Dimension for Calculating Overturning Uplift) ril,, SUMMARY(ALL VALUES ARE ASD) Method Used="ASCE 7-10-Section 29.5.1" D= 1.392 x 103 lb " WWindUpliftASD=708 lb Displacement="Fan Unit" (From ACSE 29.5-3) g, EASD=3511b hseismic=3.25 ft 125 WWindASD=957 lb (From ACSE 29.5-2) S.,. n X=4.333 ft hwind=2.667ft TWindTotalASD=525 lb Notes: TseismicASD=—155 lb 1.Positive sign convention shown.Negative values indicate opposite direction 2.X equals the width between attachment points for overturning ILAK W • ' Wind and Seismic Loads on Mechanical Unit Worksheet Calculates the wind and seismic forces for a rooftop mounted mechanical unit based on the ASCE 7-10. Hold down forces are calculated based on 0.6D+ (0.6W or 0.7E) load cases. Wind and Seismic Loads on Mechanical Unit Windspeed:= 120mph Exposure:_ "B" asd no (Is wind speed ASD?) Seismic Parameters SDS:_ .720 ap := 2.5 RP := 6.0 1E := 1.0 Building Dimensions Category:_ "II" Roof Elevation:= 20ft Building_Width:= IOOft Building_Depth:= 47ft Mechanical Unit Dimensions Displacement:_ "Fan Unit" T Unit Ca Weight:= 8101b UnitHeight := 42in Width:= 47in Length:= 75in Curb:= 14in Curb_Width:= 39in (Dimension for Calculating Overturning Uplift) SUMMARY(ALL VALUES ARE ASD) Method Used = "ASCE 7-10-Section 29.5.1" D= 810 lb WWindUplifASD=471 lb Displacement= "Fan Unit" (From ACSE 29.5-3) EASD =2041b hseismic=2.917 ft WWindASD=710 Ib (From ACSE 29.5-2) h =2.333 ft X=3.25 ft Wind TWindTotalASD=502 lb Notes: TseismicASD=—60 lb 1.Positive sign convention shown.Negative values indicate opposite direction 2.X equals the width between attachment points for overturning #11Vflk C tp SUBMITTAL Project -Untitled I Date Monday, June 24, 2019 Table Of Contents Project: -Untitled1 06/24/2019 Prepared By: 01:09PM 12.5T 3 Unit Report 4 Certified Drawing 5 Performance Summary 7 6T 10 Unit Report 11 Certified Drawing 12 Performance Summary 15 Packaged RTU Builder(Bryant) 1.29q Page 2 of 17 12.5T Project: -Untitled1 06/24/2019 Prepared By: 01:09PM 12.5T Tag Cover Sheet Unit Report Certified Drawing Performance Report Packaged RTU Builder(Bryant) 1.29q Page 3 of 17 Unit Report For 12.5T Project: —Untitledl 06/24/2019 Prepared By: 01:09PM Unit Parameters Dimensions(ft. in.)&Weight(1b.)*** Unit Model. 580JE14D224A3A0AD Unit Length. 7'4.125" Unit Size- 14(12.5 Ton) Unit Width. 4' 11.5" Volts-Phase-Hertz. 460-3-60 Unit Height 4' 1.375" Heating Type.e' Gas *** Weights and Dimensions are approximate.Weight does not include roof curbs,unit packaging,field installed accessories or factory Duct Cfg Horizontal Supply/Horizontal Return installed options. Approximate dimensions are provided primarily for Two Stage Cooling 08-16 shipping purposes.For exact dimensions and weights,refer to appropriate 224,000 product data catalog. Total Operating Weight 1118 lb Lines and Filters Gas Line Size. 3/4 Condensate Drain Line Size. 314 Return Air Filter Type: Throwaway Return Air Filter Quantity. 4 Return Air Filter Size. 20 x 20 x 2 Unit Configuration Al/Cu-Al/Cu High Static Option(Belt Drive) Standard Packaging and 2-Speed Indoor Fan Motor(VFD)Controller Controls for economizer with W7220 2-Speed indoor fan motor controlled by VFD Warranty Information 1-Year parts(std.) 5-Year compressor(str No optional warranties were selected. _ NOTE: Please see Warranty Catalog 500-089 for explanation of policies and ordering methods. Ordering Information Part Number Description Quantity 580JE14D224A3A0AD Rooftop Unit 1 Base Unit High Static Option(Belt Drive) Packaged RTU Builder(Bryant) 1.29q Page 4 of 17 Certified Drawing for 12.5T Project: -Untitled1 ll 06/24/2019 Prepared By: 01:09PM NOTES. UNITED P.O.BOX MOOD THIS DOCUMENT IS THE PROPERTY Of CARRIER CORPORATION SUBMISSION OF THESE DRAWINGS OR DiCUMENTS 1. DI NENSIONS ARE IN INCHES, DI NINENSIONS UNIT H J K TECHNOLOGIES SYRACUSE.NT AND IS DELIVERED UPON THE EXPRESS CONDITION THAT THE DOER NOT CONSTITUTE PART PERFORMANCE OR CARRIER I3111 000005CONTEN15 WILL NOT BE DISCLOSED OR USED WITHOUT CARRIER ACCEPTANCE 00 CONTRACT. IN f I ARE IN MILLIMETERS. 11 3/8 49 3/8 35 5/8CORPORATION'S WRITTEN CONSENT. 580J-14D 12891 112531 19051 2. Iii CENTER OF GRAVITY CONNECTION SIZES 40-3/8 3.0110,,DIRECTION OF AIR FLOW [1026] 1 A 1 3/8' [35] DIA FIELD POWER SUPPLY HOLE B 2 1/2" [641 DIA POWER SUPPLY KNOCKOUT -7 C 1 3/4' [577 DIA GUAGE ACCESS PLUG ECONOMIZER HOOD 20-3/4 D 7/8' [221 DIA FIELD CONTROL WIRING HOLE /OPTIONAL/ [5261 E 3/4"-14 NPT CONDENSATE DRAIN • .3 �� - F 3/4"-14 NPT OHS CONNECTION AG 2 ' [511 DIA POWER SUPPLY KNOCK-OUT • • j FILTER ACCESS PANEL • (DISPOSABLE FILTERS) �j �� \ 36-3/8 CONDENSER ��% \ RETURNAIR [321]8 THOU-THE-BASE CHART �%�_ I 1 RETURN THESE HOLES 2 IT FOR USE _ //ice- \��fII�IIII AIR COIL II •• CRB7M 00 A 1, 04A01 INDOOR COIL ,`I�IIIIIIIII�IIIIIIINw; �NIIIIIIII -• THREADED WIRE REO'D HOLE 1„'`,.,\\,,,.."., ��� CONDUIT SIZE USE SIZES )MAA./ ACCESS PANEL 40-3/6 W 1/2” ACC. 7/8" 122.2) • [1027] B 1/2" 240 7/8" 122.2) \ice 28-3/4 Y 1 1/4" 1102,004) POWER 1 3/4' 144.4) µ • [7311 37-5/8 Z. 10041 3/4" FPT GAS 1 5/8' [41.3) } [ 1% SUPPLY [955] O O : : I I .L OOnf 4 J Y AIR FOR 'THRU-THE-BASEPAN" FACTORY OPTION, 18 16 } 1 Z SUPPLY FITTINGS FOR ONLY%, Y, 8 Z ARE PROVIDED BACK [469114121[355114 [3701 THAU-THE-BASESES + AIR X (0021 PROVIDES 3/4"FPT THRU CURB ' J ,-,,,, ,CHARM•••• •. ,✓ I FLANGE &FITTING. 1 I ' 10 L 4 - 6-1/4 11591 29-5/B [1001 r 14� ..--- 3-1/4 1356] 181] [751] H E ALT. 2 11 CONDENSATE V- 25-1/2 149.11 71-7/B 4-5/8 DRAIN OPENING 1646] 11181 IN BASEPAN [3021 Iill, ELECTRICAL - 'DISCONNECT r LOCATION A, CONTROL BO% ACCESS PANELWII G CONDENSER OPTIONALIII FILTER FACTORY ® INDOOR BLOWER E STD. COIL , J INSTALLED ACCESS FLUE CONDENSATE 36 DLSCONNECT HOOD DRAIN p OPTIONAL 1913]FACTORY INSTALLEDHANDLEr/ 26 OUTCONVEW ,., OULET IENCE C �•.�N+ pF �A6.4Bp HANDLE 1334113-1/8 �' [706]27_3/4 [6491 AIRS)DE [, I SUPPLY AIR I'IL • 41111 8�- =�8 [168] �I00 I I �-- + 2-5/6 195]4 59-1/2 [67] 37 [82141 [1571 III [177] [1510] TYP _ [940] -~ 6-5/8CURB 6-1/8 II LEFT WIDTH 88[218-3/418 687 37-7/8 55] [963] BAROMETRIC FRONT 42-3/8 RELIEF (1076]V IL FLOW AIR RIGHT SHEET DATE SUPIRCEDES 580J 14 SINGLE ZONE ELECTRICAL REP 1OF2 10/07/08 07-22-08 COOLING WITH GAS HEAT 48TM501444 4. 0 Packaged RTU Builder(Bryant) 1.29q Page 5 of 17 P !Ill 1111 Certified Drawing for 12.5T Project: -Untitled1 06/24/2019 01:09PM Prepared By: UNITED P.O.BOX 1806 IS DOCUMENT IS TXE PROPERTY OP CARRIER CORPGSHTIOM SUBMISSION Of 1X[54 DAANIN65 OA DOCUMENTS TECHNOLOGIES SYRACUSE.NY AND IS DELIVERED UPON TND EXPRESS CONDITION THAI Ill UBM5 SIO[OX3TI T[PART PEREOR000WA OR CARRIER 13001 CONTINlS NILS RIF IE DISCSDSID OR USED RITROUT CARRIER ACCEPT DOE CONTRACT. STD. UNIT CORNER CORNER CORNER CORNER C G tORPORAIIDX'S RRIIIEX CONSENT. UNIT WEIGHT WEIGHT (A) WEIGHT (B) WEIGHT (C) WEIGHT (D) LBS. KG. LBS. NG. LBS. KG. LBS. KG. LBS. NG. X Y Z 560J-14D 1116 506 297 135 157 71 229 104 434 197 29 1/2 (749) 34 1/4 (870) 20 114 (514) CORNER A 4 N .. - CORNER B IIII��Iu11��SIIIIIIIIII I ) 1. CORNER D L ..- CORNER C _ TOP . 1 0I. 'I IiOO = = : : 00..2 FRONT SHEET DATE SUPIRCEDES 580J 14 SINGLE ZONE ELECTRICALREP zoEz 10/07/08 07-22-08 COOLING WITH GAS HEAT 48TM501444 4, Packaged RTU Builder(Bryant) 1.29q •Page 6 of 17 111 • Performance Summary For 12.5T Project: -Untitledl 06/24/2019 Prepared By: 01:09PM Part N um ber:58OJ E 14D224A3A0AD ARI EER- 10.80 IEER: 12.2 Base Unit Weight. 1118 lb Base Unit Dimensions Unit Length. 88.1 in Unit Width 59.5 in Unit Height: 49.4 in Unit Unit Voltage-Phase-Hertz. 460-3-60 Air Discharge. Horizontal Fan Drive Type. Belt Actual Airflow. 5000 CFM Site Altitude. 0 ft Cooling Performance Condenser Entering Air DB: 95.0 F Evaporator Entering Air DB- 80.0 F Evaporator Entering Air WB: 67.0 F Entering Air Enthalpy. 31.44 BTU/lb Evaporator Leaving Air DB: 60.5 F Evaporator Leaving Air WB• 57.7 F Evaporator Leaving Air Enthalpy. 24.83 BTU/lb Gross Cooling Capacity 148.67 MBH Gross Sensible Capacity 105.37 MBH Compressor Power Input. 10.20 kW . Coil Bypass Factor 0.254 Heating Performance Heating Airflow. 5000 CFM Entering Air Temp• 70.0 F Leaving Air Temp. - 104.1 F Gas Heating Input Capacity: - - 180.0/224.0 MBH Gas Heating Output Capacity 147.0/184.0 MBH Temperature Rise- 34.1 F Thermal Efficiency(%)• 82.0 Supply Fan External Static Pressure. 0.50 in wg Fan RPM• 950 Fan Power 3.14 BHP NOTE: . The Selected Indoor Fan Motor requires a Field-Supplied Drive(RPM Range: 1022-1240). Electrical Data Voltage Range: 414-506 Compressor#1 RLA• 8.2 Compressor#1 LRA- 66 Compressor#2 RLA• 10.6 Compressor#2 LRA• 75 Indoor Fan Motor Type• HIGH Indoor Fan Motor FLA: 6.4 Combustion Fan Motor FLA(ea). 0.25 Power Supply MCA. 31 Power Supply MOCP(Fuse or HACR). 40 Disconnect Size FLA. 33 Disconnect Size LRA: 201 Electrical Convenience Outlet. None Packaged RTU Builder(Bryant) 1.29q Page 7 of 17 Performance Summary For 12.5T Project: -Untitledl 06/24/2019 Prepared By: 01:09PM Outdoor Fan[Qty/FLA(ea)]. 1 /3.1 Control Panel SCCR: 5kA RMS at Rated Symmetrical Voltage - Acoustics Sound Power Levels, db re 10E-12 Watts Discharge Inlet Outdoor 63 Hz 99.9 95.7 87.0 125 Hz 96.6 85.1 85.2 250 Hz 85.7 75.7 84.6 500 Hz 77.0 67.2 84.9 1000 Hz 74.2 66.1 82.2 2000 Hz 72.0 65.4 78.4 4000 Hz 76.4 66.5 75.3 8000 Hz 78.3 67.4 72.9 A-Weighted 85.6 76.3 87.0 Advanced Acoustics IS a 4 s . f `\ 4*c \\\ aNI Advanced Accoustics Parameters 1. Unit height above ground. 30.0 ft 2. Horizontal distance from unit to receiver: 50.0 ft 3. Receiver height above ground. 5.7 ft 4. Height of obstruction. 0.0 ft 5. Horizontal distance from obstruction to receiver: 0.0 ft 6. Horizontal distance from unit to obstruction- 0.0 ft Detailed Acoustics Information Octave Band Center Freq. Hz 63 125 250 500 1k 2k 4k 8k Overall A 87.0 85.2 84.6 84.9 82.2 78.4 75.3 72.9 92.4 Lw B 60.8 69.1 76.0 81.7 82.2 79.6 76.3 71.8 87.1 LwA C 54.6 52.8 52.2 52.5 49.8 46.0 42.9 40.5 60.0 Lp D 28.4 36.7 43.6 49.3 49.8 47.2 43.9 39.4 54.7 LpA Legend _ A Sound Power Levels at Unit's Acoustic Center, Lw B A-Weighted Sound Power Levels at Unit's Acoustic Center, LwA C Sound Pressure Levels at Specific Distance from Unit, Lp D A-Weighted Sound Pressure Levels at Specific Distance from Unit, LpA Packaged RTU Builder(Bryant) 1.29q Page 8 of 17 Performance Summary For 12.5T Project: —Untitled1 06/24/2019 Prepared By: 01:09PM Calculation methods used in this program are patterned after the ASHRAE Guide; other ASHRAE Publications and the AHRI Acoustical Standards. While a very significant effort has been made to insure the technical accuracy of this program, it is assumed that the user is knowledgeable in the art of system sound estimation and is aware of the tolerances involved in real world acoustical estimation. This program makes certain assumptions as to the dominant sound sources and sound paths which may not always be appropriate to the real system being estimated. Because of this, no assurances can be offered that this software will always generate - an accurate sound prediction from user supplied input data. If in doubt about the estimation of expected sound levels in a space, an Acoustical Engineer or a person with sound prediction expertise should be consulted. FanCurve 20 - 1 - 1103RPM 123ORRM 1 is-,- ,, s-- 400FiPM 18 14 \ &CR M X12 22 10 700RPM CL \ U 08 BOORFM 06 50oRPM n4 a00RPM ..00BHP \ X2.00' 1 1 1 1 1 1 I I 11 1.111 \I MM. �I 1 1 T I 0.75BH' \1.00BHP 1.50BHP CO Q7 14 21 28 35 42 49 63 70 Airrilaw(CFM-thousands) RPM=950 BHI'=3.14 MaximumRPM=1400 MaximumHP=4.70 Note:Pleasecontactapplicationengineeringforselectionsoutsidetheshadedregion. SC-SystemCurve RP-RatedPoint Packaged RTU Builder(Bryant) 1.29q Page 9 of 17 6T Project: -Untitled1 06/24/2019 Prepared By: 01:09PM 6T Tag Cover Sheet Unit Report Certified Drawing Performance Report Packaged RTU Builder(Bryant) 1.29q Page 10 of 17 Unit Report For 6T Project: -Untitled1 06/24/2019 Prepared By: 01:09PM • , Unit Parameters Dimensions(ft. in.)&Weight(1b.)*** Unit Model. 582KE07N110A2A0AC Unit Length. 6'2.375" Unit Size• 07(6 ton) Unit Width. 3' 10.625" Volts-Phase-Hertz. 460-3-60 Unit Height: 3'5.375" Heating Type• Gas *"* Weights and Dimensions are approximate.Weight does not include roof Duct Cfg• Horizontal Supply/Horizontal Return curbs,unit packaging,field installed accessories or factory installed options. Approximate dimensions are provided primarily for Two Stage Cig/Single Circuit with Alum Exchanger(07 only) shipping purposes.For exact dimensions and weights,refer to appropriate 110,000 product data catalog. Total Operating Weight. 607 lb Lines and Filters Return Air Filter Type• Throwaway Return Air Filter Quantity. 4 Return Air Filter Size• 16 x 16 x 2 Unit Configuration Al/Cu-Al/Cu Medium Static Vane Axial Fan Option EM controls.Allows for use of all field installed economizers and dampers Standard Packaging, electro mech. controls that require W7220 EconoMi$er X Controls for economizer with W7220 Warranty Information 1-Year parts(std.) 5-Year compressor(std.) 10-Year aluminized heat exchanger(std.) No optional warranties were selected. NOTE: Please see Warranty Catalog 500-089 for explanation of policies and ordering methods. Ordering Information Part Number Description Quantity-'- 582KEO7N110A2A0AC Rooftop Unit 1 Base Unit Medium Static Vane Axial Fan Option Packaged RTU Builder(Bryant) 1.29q Page 11 of 17 Certified Drawing for 6T Project: —Untitled1 06/24/2019 Prepared By: 01:09PM THIS DOCUMENT IS THE PROPERTY Of Ulf CLIMATE,CONTROLS SRRMISSIOM M THESE DxANENGS DA DOCUMENTS NOTES: UNIT J K Iir T lit•S SECURITY CONSENT. DELIVEREDSSPAN THE(SPREES CONDITION ODES MOO COf THOSE PART GS OORMAN[E OR AttuuTCE OE GS TRAIT. 1. DIMENSIONS ARE IN INCHES, DIMENSIONS 5821(404 33 3/8 18 5/8 IN [ I ARE IN MILLIMETERS. [8471 1472] CONNECTION SIZES 2.& CENTER OF GRAVITY 5821(405 33 318 TO 7/8 [847] 1371] 33-3/8 A 1 3/8" [357 DIA FIELD POWER SUPPLY HOLE 5621(x06 33 3/8 14 7/6 18481 B 2" 1501 DIA POWER SUPPLY KNOCKOUT 3, 000,DIRECTION OF AIR FLOW [847] [3777 _ 5621(MO7 41 3/8 18 5/8 32-1/8 ' ECONOMIZER HOOD ' C 1 3/4' [51] DIA GAUGE ACCESS PLUG 4. ALL VIEW DRAWN USING 3RD ANGLE [10511 f4 2 [8171 (OPTIONAL) D 7/8' [22] DIA FIELD CONTROL WIRING HOLE 16 E 3/4'-14 NPT CONDENSATE DRAIN 407] 25-5/8 F 1/2'-14 NPT GAS CONNECTION [6521 RETURN AIR I 0 2 1/2 " 1641 DIA POWER SUPPLY KNOCK-OUT . �f THRU-THE-BASE CHART �Il ,', "C� 10-7/e THESE HOLES REQUIRED FDR USE \�`�\ o -� [2771 RETURN CRBTWROD8A00. IRE 0 �l�Il�//1111/ 1 AIA THREADED WIRE AEO'D HOLE ���������������®7������lI7I/ CONDUIT SIZE USE SIZES IMA%,) \\''' —..� " p (� 11 1 W ,/2" „5V ,/6' 122.2] ♦ - \ .. J Jj 1/2' 24V 7/8' [22.21 44-1/8 / 29-1/2 Y 3/4' POWER 1-1/6" [28.6] [1120.91 -_-_ Y E ALT. _ 17-3/7 [7487 24 (DOGGIE) 1/2" FPT GAS 1-1/B" 128.61 CONDENSATE W • Z DRAIN OPENING [4511IMO. FOR'THRU-TME-BASEPAN" FACTORY OPTION, IN BASEPAN SUPPLY 26-5/8 x FITTINGS FOR ONLY%, Y, A Z ARE PROVIDED • AIR [675] SUPPLY 1008800) PROVIDES 3/4' OPT THRU CURB 14-1/2 1 _ AIR FLANGE 6 FITTING. 13691 12-1/2 11-1/2 - SEE THRU THE % ! [31;Y A] [293] BA•SE LHAR•T--_- .A. ti 4, 3-1/4 6-1/4 12-116- 2%1303141611 [1581 [256] [603] 4 FLUE I 12-118 _ [101] HOOD V�1307] K L-- 2% 25 18-3/8 [6357 [466] All z%/-5/5 TOP 11181 E STD. CONDENSATE 10-7/8 r 1 ELECTRICAL DRAIN 1275] [251 DISCONNECT _ _ .. ®� 1 .1 . LOCATION 9 l---i FILTER COIDENSEA 111._ A,B,G OPTIONAL BOX ACCESCONTRS PANEL - INDOOR BLOWER 17-3/6 1166311 INSTALLED 1441/ R ETUAN MO. OPTIONAL r�d - P� .-- I AIA I _ DISCONNECT ACCESS PANEL • SUPPLY AIR tI FACTORY = `� INSTALLED :80 ' F HANDLE it-1/8 I_I21-1/4./[ [539] OUTSIDE OIEII' O L� J- .�. I6- f28771 - .. - --�_--_ 41111. MINIM HANDLE 5-3/4 6-3/8 7 5-3/4 3-3/4 46-5/B I - 8-3/8 [, 461 MIMI [ 161] [177] [146] [951 11186] 30-1/8 26-7/6 17667 [682] 74-3/8 31 BAROMETRIC LEFT 110 1 [18891 [786] RELIEF FLOW FRONT AIR 41, AllRETURN RIGHT AIR ITC CLASSIFICATION SHEET DATE SUPERCEDES582N Od-Ol SINGLE PACKAGE ELECTRICAL REV " U.S. ECC N:NSR 1 OF 3 09/07118 06/22/18 COOLING WITH GAS HEAT 48TC003095 A Packaged RTU Builder(Bryant) 1.29qPage 12 of 17 C.. r ifi ci Drawing for 6T Project: --Untitled1 9 06/24/2019 Prepared By: 01:09PM b ry a nt THIS DOCUMENT IS Tx[PROPERTY OF UTC CLIMATE.CONTROLS SUBMISSION M THESE DRAWINGS DR DOCUMENTS S SECURITY AND IS DELIVERED UPON Ix[(UPRISE COXDIT ION DOSS NOT CONSTITUTE PART IERFORNAXCC OR STD. UNIT CORNER CORNER CORNER LOANER NRIT Ix[CNSENT. NUL NOT DE DISCLOSED NITNWI ACCEPTAMCE Of CONTRACT UNIT WEIGHT N WEIGHT (A) WEIGHT (B) WEIGH] (C) WEIGHT (D) C,G. HEIGHT B RIIIEM COXSEXi. LBS. KG. LBS. KG. LBS. KG. LBS. KG. LBS. KG. 0 Y Z 5821X04 482 219 113 51 116 53 128 58 125 57 37 5/8[956] 24 9/16 [624] 18 1/4 14641 5821005 543 246 138 63 133 60 133 60 138 63 36 1/2 [927] 23 3/8 [5941 18 [457] 5826N06 556 252 142 64 136 62 136 62 142 64 36 1/2 [9271 23 3/8 [5941 18 [4571 5821X07 607 275 162 73 152 69 141 64 151 68 36 [9141 22 I/O [572] 19 3/8[492) N STANDARD UNIT WEIGHT IS WITH LOW GAS HEAT AND W TROUT PACKAGING. FOR OTHER OPTIONS AND ACCESSORIES, REFER TO THE PR UCT DATA CATALOG. 1 BACK BACK \ R12 1/2 WITH ECONOMIZER [3181 . CORNER A CORNER g WITHOUT 1 ECONOMIZER HOOD ECONOMIZER OPTIONAL DOOR \ • (OPTIONAL) • 3 � 1 SWING O hT iii==. \\\\` RIGHT ILLLI::11 p111««\71. ) X1,/, •S CORNER D " r -J (CORNER C LEFT X u TOP — 74-5/8 010961 FRONT • NOTES: 1. FOR ALL MINIMUM CLEARANCES LOCAL CODES OR JURISDICTIONS MAY PREVAIL. Z CLEARANCE . SERVICE WITH: SERVICE WITH: OPERATMO RRI — SURFACE CONDUCTIVE BAER NONCONDUCTIVE BMW CLEARANCE it 0 1.--•,.....1 1110111 •• FRONT 48 [1219mm] 36 (914mm] 18 (457mm] LEFT 48 [1219mm] 42 (1067mm] 16 [457mm] FRONT BACK 48 (1219mm] 42 (1067mm] 16 I457mm] BACK W/HOOD 36 [914mm] 36 (914mm] 18 [457mm] NWT 36 [914mm1 36 (914mm] 18 (457mm] TOP 72 I1829mm] 72 [1829mm] 72 [182Snim] ITC CLASSIFICATION SHEET DATE SUPERCEDES 582K 04-07 SINGLE PACKAGE ELECTRICAL REV U.S. ECCN:NSR 2 OF 3 09/07/18 06/22/18 COOLING WITH GAS HEAT 481C003095 A Packaged RTU Builder(Bryant) 1.29q Page 13 of 17 Certified Drawing for 6T Project: -Untitled1 06/24/2019 Prepared By: 01:09PM �1 11 —' THIS DOCUMENT ES THE PROPERLY OF UTC CLIMATE.CONTROLS 6UNMISSION Of iH1FJ[DRANIN65 OR CIXUM[Nl6 [ J a ' ri,R iciSNM l WILLYNOT BE DISCLOSEDPN101001 DIIION S NOIACCEPTA11RE01 CONTRACTT...VC DR --.WRITTEN CONSEHI. ---- 71-1/8 [1805.3] (INSIDE THE BASE RAIL 8 SKIRT) a _ J ...........''''.... M 41-1/4 O (INSIDE[THE4 BASE RAILS) �/ ,. ^ /% • / U f 400111011.1"/ 9155:7)114 vv " 'i���� �l� INSIDE BASERAIL DIMENSIONS 2%1 T 8 l 11.-01::3v- 4111t. jG I, 2%1-3/4 �.�illibi /� E 116] ki BOTTOM 1481 �TA��,I 1-3/8 2X 1 3-1/4 [36] (251 [82I — 2X 3/4 3-7/8 ..,_ [18] DETAIL C [991 TYP 4 PLCS • FILTER ACCESS PANEL COMP. CONDENSER CONTROLPBOX BOXL INDOOR BLOWER (TOOL-LESS) ACCESS COIL ANEL . - PANEL O INDOOR COIL _ "I �I SEE DETAIL C ACCESS PANEL do• +p 147.67/87 :100 1 1 "( JI..--i 1 J I OOC:I di:1��)Ei ij1 1JIIIII p I 'I—P I - I 1' al BACK LEFT 3-1/4 Il. 59-3/8 z-3/e [82.01 /1509.01 161P CURB [ 80.7] FROM WIDTH ITC CLASSIFICATION SHEET DATE SUPERCEDES 582804-07 SINGLE PACKAGE ELECTRICAL REV 48TC003095 U.S. ECCN:NSR 3 01 3 09/01/18 06/22/18 COOLING WITH GAS HEAT A Packaged RTU Builder(Bryant) 1.29q 1 Page 14 of 17 Performance Summary For 6T Project: —Untitled1 06/24/2019 Prepared By: 01:09PM -Part Number:582KEO7N110A2A0AC ARI EER• 11.00 IEER. 15.0 Base Unit Weight 607 lb Base Unit Dimensions Unit Length. 74.4 in Unit Width. 46.6 in Unit Height 41.4 in Unit Unit Voltage-Phase-Hertz. 460-3-60 Air Discharge- _Horizontal Fan Drive Type. Direct Actual Airflow. 2400 CFM Site Altitude: 0 ft Cooling Performance Condenser Entering Air DB• 95.0 F Evaporator Entering Air DB- 80.0 F Evaporator Entering Air WB. 67.0 F Entering Air Enthalpy 31.44 BTU/lb Evaporator Leaving Air DB• 58.5 F Evaporator Leaving Air WB: 57.5 F Evaporator Leaving Air Enthalpy. 24.73 BTU/Ib - Gross Cooling Capacity- 72.42 MBH Gross Sensible Capacity 55.62 MBH Compressor Power Input 5.29 kW Coil Bypass Factor. 0.096 Heating Performance - Heating Airflow- 2400 CFM Entering Air Temp• 70.0 F Leaving Air Temp.r. = 104.0 F Gas Heating Input Capacity 110.0 MBH Gas Heating Output Capacity 88.0 MBH Temperature Rise- 34.0 F Thermal Efficiency(%). 80.0 Supply Fan External Static Pressure. 0.50 in wg Fan RPM- 2081 Fan Power. 0.95 BHP NOTE Selected IFM RPM Range: 253-2530 Electrical Data Voltage Range- 414-506 Compressor#1 RLA- 8.4 Compressor#1 LRA• 66 Indoor Fan Motor Type• MED Indoor Fan Motor FLA• 2.2 Combustion Fan Motor FLA(ea)* 0.25 Power Supply MCA. 14 Power Supply MOCP(Fuse or HACR)• 20 Disconnect Size FLA. 13 Disconnect Size LRA• 71 Electrical Convenience Outlet None Outdoor Fan [Qty/FLA(ea)]. 1 /0.8 Control Panel SCCR: 5kA RMS at Rated Symmetrical Voltage Packaged RTU Builder(Bryant) 1.29q Page 15 of 17 Performance Summary For 6T Project: -Untitled1 06/24/2019 Prepared By: 01:09PM Acoustics Sound Power Levels, db re 10E-12 Watts Discharge Inlet Outdoor 63 Hz 90.3 88.4 85.6 125 Hz 81.5 78.4 84.7 250 Hz 75.8 71.0 80.5 500 Hz 74.1 65.5 76.0 1000 Hz 70.6 68.0 72.4 2000 Hz 68.3 59.2 68.0 4000 Hz 64.2 52.2 62.8 8000 Hz 60.1 46.8 59.3 A-Weighted 76.8 71.6 79.0 Advanced Acoustics a0 .._. _ 0 l' 114 I . ... ,_rt. y E � Is?) , 0 I P44 ` i Advanced Accoustics Parameters 1. Unit height above ground. 30.0 ft 2. Horizontal distance from unit to receiver. 50.0 ft 3. Receiver-height above ground: 5.7 ft 4. Height of obstruction. 0.0 ft 5. Horizontal distance from obstruction to receiver. 0.0 ft 6. Horizontal distance from unit to obstruction• 0.0 ft Detailed Acoustics Information Octave Band Center Freq. Hz 63 125 250 500 1k 2k 4k 8k Overall A 85.6 84.7 80.5 76.0 72.4 68.0 62.8 59.3 89.2 Lw B 59.4 68.6 71.9 72.8 72.4 69.2 63.8 58.2 78.5 LwA C 53.2 52.3 48.1 43.6 40.0 35.6 30.4 26.9 56.8 Lp D 27.0 36.2 39.5 40.4 40.0 36.8 31.4 25.8 46.1 LpA Legend A Sound Power Levels at Unit's Acoustic Center, Lw B A-Weighted Sound Power Levels at Unit's Acoustic Center, LwA C Sound Pressure Levels at Specific Distance from Unit, Lp _ D A-Weighted Sound Pressure Levels at Specific Distance from Unit, LpA Calculation methods used in this program are patterned after the ASHRAE Guide; other ASHRAE Publications and the AHRI Acoustical Standards. While a very significant effort has been made to insure the technical accuracy of this program, it is assumed that the user is knowledgeable in the art of system sound estimation and is aware of the tolerances involved in real world acoustical Packaged RTU Builder(Bryant) 1.29q Page 16 of 17 Performance Summary For 6T Project: —Untitledl 06/24/2019 Prepared By: 01:09PM estimation. This program makes certain assumptions as to the dominant sound sources and sound paths which may not always be appropriate to the real system being estimated. Because of this, no assurances can be offered that this software will always generate - . an accurate sound prediction from user supplied input data. If in doubt about the estimation of expected sound levels in a space, an Acoustical Engineer or a person with sound prediction expertise should be consulted. 3D FanCurve 28 27 26 25 111 41111 24 -...-r N 23 22 \4,z, 19 „.„.11111,„,41 4 18 17 D 16 - 'ill 1111 i ui 15 21.4 1101 444 d 13 u 12 " 11 2.00: (n 1D 09 Jo-.05 BHP 03 ft ....-.. igh"" � ... :��-- �� ice_ _�111111.011111 .7": �=mg cr, ................„ i co , , , , , , , , m 02 04 06 a6 1D 12 14 16 18 20 22 24 26 28 30 Airflow(CFM-thousands) RPM=2081 BHP=0.95 MaximunaRPM=2836MaximumHP=3.00 SC-SystemCurve RP-RatedPoint Packaged RTU Builder(Bryant) 1.29q Page 17 of 17 (7/(-//(r / s , Product Data Carrier WeatherMaker® Single Packaged Rooftop Gas Heat/Electric Cooling 6 to 15 Nominal Tons .0 WeatherMaker 4 . 4 4,. r Pets-'` /'' .,- ,. I' •.,C:o�- `. . �'"_..--�""_ 'vx^ 'moi �, ;F' �. ^�-.`.-_.,,w..-.. f +-rY "' »..- u 44-1;443 -r..._,,,,,-- C .. ' A ..:+- _ rca `. u5 w ..,.� Ppm' s NNW '11X 48TC 07, 08,09, 12, 14, 16 with Puron®(R-410A) Refrigerant ©Carrier Corporation 2018 Form 48TC-7-16 02PD Model number nomenclature (arrier) Position: 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Example: 4 8 TCDD 0 8 A 1 A 5 - 0 A 0 GO Unit Heat Type Packaging Compliance 48-Gas Heat Packaged Rooftop 0= Standard 1 = LTL Model Series-WeatherMaker° TC-Standard Efficiency Electrical Options Non USA Models—No SAV included A=None Heat Options C=Non-Fused Disconnect D= Low Heat D=Thru-The-Base Connections E= Medium Heat F=Non-Fused Disconnect and F= High Heat Thru-The-Base Connections S= Low Heat w/Stainless Steel Exchanger Standard USA Models—SAV included R= Medium Heat w/Stainless Steel Exchanger G=2-Speed Indoor Fan(VFD)Controller T= High Heat w/Stainless Steel Exchanger J =2-Speed Fan Controller(VFD)and Non-Fused Disconnect Refrig.Systems Options K=2-Speed Fan Controller(VFD)and A= One Stage Cooling Models(Size 07 Only) Thru-The-Base Connections B= One Stage Cooling Models with M=2-Speed Fan Controller(VFD) Humidi-MiZer°(Size 07 Only) with Non-Fused Disconnect and D=Two Stage Cooling Models 08-16 Thru-The-Base Connections E= Two Stage Cooling Models 08-16 with Al/Cu condenser Coils and with Humidi-MiZer Service Options M= Single Circuit,Two Stage Cooling Models 0= None (Sizes 08,09,12 Only) 1 = Unpowered Convenience Outlet 2= Powered Convenience Outlet Cooling Tons 3= Hinged Panels 07=6 tons 12=10 tons 4= Hinged Panels and 08=7.5 tons 14=12.5 tons Unpowered Convenience Outlet 09=8.5 tons 16=15 tons 5= Hinged Panels and Powered Convenience Outlet Sensor Options Intake/Exhaust Options A= None A= None B= RA Smoke Detector C= SA Smoke Detector B=Temperature Economizer w/Barometric Relief D= RA+SA Smoke Detector F= Enthalpy Economizer w/Barometric Relief E= CO2 K= 2-Position Damper F= RA Smoke Detector and CO2 U=Temperature Ultra Low Leak Economizer G= SA Smoke Detector and CO2 w/Barometric Relief • H= RA+SA Smoke Detector and CO2 W= Enthalpy Ultra Low Leak Economizer J = Condensate Overflow Switch(electro-mechanical controls only) w/Barometric Relief K= Condensate Overflow Switch and RA Smoke Detectors L= Condensate Overflow Switch and RA and SA Smoke Detectors Base Unit Controls - 0= Electro-mechanical Controls can be used with W7212 Indoor Fan Options EconoMi$ert IV(Non-Fault Detection and Diagnostic) 1 = Belt Drive,Standard Static Option 1 = PremierLink^"Controller 2= Belt Drive,Medium Static Option 2= RTU Open Multi-Protocol Controller 3= Belt Drive,High Static Option* 6= Electro-mechanical w/2-Speed Fan and W7220 C= High Static Option with High Efficiency Motor(Size 16 Only)_. Economizer Controller Controls.Can be used with W7220 EconoMi$er X(w/Fault Detection and Diagnostic) Coil Options–RTPF(Outdoor-Indoor-Hail Guard) A= Al/Cu-Al/Cu Design Revision B= Precoat Al/Cu-AUCu - = Factory Design Revision C= E-coat Al/Cu-AUCu D= E-coat AUCu-E-coat Al/Cu Voltage E= Cu/Cu-Al/Cu 1 = 575/3/60(not available for 48TC_MO8 units) F= Cu/Cu-Cu/Cu 5= 208-230/3 M= At/Cu-Al/Cu—Louvered Hail Guard 6=460/3/60 N= Precoat Al/Cu-Al/Cu—Louvered Hail Guard P= E-coat Al/Cu-Al/Cu—Louvered Hail Guard *Not available for 48TC M08 units. Q= E-coat Al/Cu-E-coat Al/Cu—Louvered Hail Guard R= Cu/Cu-Al/Cu—Louvered Hail Guard S= Cu/Cu-Cu/Cu—Louvered Hail Guard NOTE:Not all possible options are displayed,see the current Coil Options–Novation°(Outdoor-Indoor-Hail Guard) 48TC 6 to 15 Ton Price Pages for more details. G= Al/AI-Al/Cu H= Al/A1-Cu/Cu J = AI/AI-E-coat Al/Cu K= E-coat Al/AI-Al/Cu L= E-coat AUAI-E-coatAl/Cu T= Al/AI-Al/Cu—Louvered Hail Guard U= Al/AI-Cu/Cu—Louvered Hail Guard V=Al/AI-E-coat Al/Cu—Louvered Hail Guard W= E-coatAl/AI-AI/Cu—Louvered Hail Guard X= E-coat Al/A1-E-coat Al/Cu—Louvered Hail Guard UC ,�,.: i CERTIFIED, ASIIRAE Ej� t,s At www,ah[idlrectory.nrg C RnlrantLargeandar AC US MRI Standard 3401360 t�sTE° 43 � ,.�n<d��,'A!--""`"` - " n O COMPLIANT Intertek 3 Capacity ratings (arriee AHRI COOLING RATINGS - IEER WITH IEER WITH NOM. NET COOLING TOTAL SINGLE SPEED 2-SPEED 48TC COOLING REFRIGERANT CAPACITY CAPACITY POWER INDOOR FAN INDOOR FAN UNIT STAGES CIRCUITS (TONS) (MBH) (kW) EER MOTOR MOTOR A07 1 1 6.0 70.0 6.4 11.00 11.2 12.7 D08 2 2 7.5 83.0 7.5 11.00 11.7 12.8 D09 2 2 8.5 99.0 9.0 11.00 11.7 12.8 D12 2 2 10.0 114.0 10.3 11.10 11.8 12.8 D14 2 2 12.5 140.0 12.9 10.80 11.0 12.2 D16 2 2 15.0 174.0 16.1 10.80 11.5 12.4 M08* 2 1 7.5 88.0 8.0 11.00 12.7 N/A M09 2 1 8.5 97.0 8.8 11.00 12.7 N/A M12 2 1 10.0 117.0 10.6 11.00 12.7 N/A LEGEND NOTES: 1. Rated and certified under AHRI Standard 340/360,as appropriate. AHRI - Air-Conditioning,Heating and Refrigeration Institute Test Standard. 2. Ratings are based on: ASHRAE- American Society of Heating, Refrigerating and Air-Conditioning Cooling Standard:80°F(27°C)db,67°F(19°C)wb indoor. Engineers. IEER Standard:A measure that expresses cooling part load EER efficiency EER -Energy Efficiency Ratio for commercial unitary air conditioning and heat pump equipment on the basis IEER -Integrated Energy Efficiency Ratio. of weighted operation at various load capacities. IECC* -International Energy Conservation Code 3. The 48TC*D rooftops meets the DOE-2018 (Department of Energy), N/A -Not Applicable ASHRAE 90.1-2016 and IECC$-2015 minimum efficiency requirements when equipped with the SAVTM(staged air volume)option. *575V option and Hi-Static Fan option for MO8 are not available. 4. The 48TC*M rooftops meet the DOE-2018 minimum efficiency requirement without the SAV option. t IECC is a registered trademark of International Code Council,Inc PI CE � US C ® L US �,S,�oCERTIFIED. Intertek • 4 terrier United Technologies HEATING RATING TABLE - NATURAL GAS AND PROPANE AUSS HEAT EXCHANGER • 48TC INPUT/OUTPUT INPUT/OUTPUT TEMP RISE THERMAL EFFICIENCY UNITS GAS HEAT STAGE 1 (MBH) STAGE 2(MBH) (DEG F) (%o) LOW - 72/59 15- 55 82% 07 MED - 115/93 25- 65 81% HIGH 120/96 150/120 35- 80 80% LOW - 125/103 20- 50 82% 08 MED 120/98 180/148 35- 65 82% HIGH 180/147 224/184 45- 75 82% LOW - 125/103 20- 50 82% 09 MED 120/98 180/148 30- 65 82% HIGH 180/147 224/184 40- 75 82% LOW 120/98 180/148 25- 65 82% 12 MED 180/147 224/184 30- 65 82% HIGH 200/160 250/205 35- 70 80% LOW 120/98 180/148 20- 65 82% 14 MED 180/147 224/184 25- 65 82% HIGH 200/160 250/205 25- 70 80% LOW 144/118 180/146 15- 55 81% 16 MED 192/156 240/195 20- 60 81% HIGH 280/224 350/280 35- 65 80% NOTES: 1. Heat ratings are for natural gas heat exchangers operated at or below 2000 ft (610 m).For information on propane or altitudes above 2000 ft(610 m),see the Application Data section of this book.Accessory Propane/High Altitude kits are also available. 2. The input rating for altitudes above 2000 ft(610 m)must be derated by 4%for each 1000 ft(305 m)above sea level. -* SOUND PERFORMANCE 48TC COOLING OUTDOOR SOUND(db)AT 60 Hz UNIT STAGES A-Weighted 63 125 250 500 1000 2000 4000 8000 A07 1 78 88.8 81.8 76.9 74.4 73.3 69.8 66.3 62.7 M08 2 82 90.1 82.6 81.0 79.4 77.0 73.0 70.4 66.7 D08 2 82 85.8 84.3 80.5 78.7 76.4 72.7 68.3 65.1 M09 2 83 91.2 86.4 81.9 81.0 78.3 73.9 71.4 67.3 D09 2 82 88.6 85.0 81.6 79.5 77.4 74.1 71.0 66.3 M12 2 82 88.6 85.0 81.6 79.5 77.4 74.1 71.0 66.3 D12 2 82 89.0 83.1 80.5 78.5 75.5 71.6 69.6 69.3 D14 2 87 87.0 85.2 84.6 84.9 82.2 78.4 75.3 72.9 D16 2 87 87.0 85.2 84.6 84.9 82.2 78.4 75.3 72.9 LEGEND NOTES: dB -Decibel 1. Outdoor sound data is measured in accordance with AHRI standard 270. 2. Measurements are expressed in terms of sound power. Do not compare these values to sound pressure values because sound pressure depends on specific environmental factors which normally do not match individual appli- cations. Sound power values are independent of the environment and there- fore more accurate. 3. A-weighted sound ratings filter out very high and very low frequencies,to better approximate the response of"average" human ear. A-weighted mea- surements for Carrier units are taken in accordance with AHRI standard 270. 418 5 Capacity ratings (cont) Farrier a United Technologies —> MINIMUM -MAXIMUM AIRFLOW (CFM) RATINGS - NATURAL GAS AND PROPANE COOLING AL HX HEATING SS HX HEATING UNIT HEAT LEVEL Minimum Minimum Minimum 2-Speed Fan 2-Speed Fan Maximum Minimum Maximum Minimum Maximum Motor(at Motor(at High Speed) Low Speed) LOW 990 3640 990 3640 48TC**07 MED 1800 1800 1200 3000 1330 3450 1330 3450 HIGH 1390 3170 1390 3170 LOW 1900 4750 1900 4750 48TC**08 MED 2250 2250 1500 3750 2100 3900 2100 3900 HIGH 2270 3780 2270 3780 LOW 1900 4750 1900 4750 48TC**09 MED 2550 2873 1915 4250 2100 4560 2100 4560 HIGH 2270 4250 2270 4250 LOW 2100 5470 2100 5470 48TC**12 MED 3000 3380 2253 5000 2620 5670 2620 5670 HIGH 2650 5290 2650 5290 LOW 2100 6830 2100 6830 48TC**14 MED 3600 4056 2704 6000 2620 6800 2620 6800 HIGH 2650 7410 2650 7410 LOW 2450 7500 2450 9000 48TC**16 MED 4500 5625 3750 7500 3000 6750 3000 9000 HIGH 3990 7200 3990 7410 LEGEND AL HX —Aluminum Gas Heat Exchanger SS HX —Stainless Steel Gas Heat Exchanger 6 718 Physical data (cont) w r er --> PHYSICAL DATA(COOLING) - 10-15 TONS 48TC 48TC-D/E12 48TC-M12 48TC-D/E14 48TC-D/E16 . REFRIGERATION SYSTEM #Circuits I#Comp./Type 2/2/Scroll 1 /1/2-Stage Scroll 2/2/Scroll 2/2/Scroll RTPF models R-410A charge NB(lbs-oz) 10-5/10-3 21-0 11-0/11-6 15-14/16-12 - Alternate(MCHX)R.10A charge A/B(lbs-oz) 6-0/6-0 — 7-6/8-0 — Alternate(Humidi-MiZer®)R-410A charge NB(lbs-oz) 16-10/16-0 — 17-10/18-3 — Metering device Accutrol Accutrol+TXV Accutrol Accutrol - Alternate Humidi-Mizer Metering Device Accutrol+TXV — Accutrol+TXV — High-press.Trip/Reset(psig) 630/505 630/505 630/505 630/505 Low-press.Trip/Reset(psig) 54/117 54/117 54/117 54/117 Compressor Capacity Staging(%) 50%/100% 66%/100% 50%/100% 50%/100% EVAP.COIL Material Cu/Al Cu/Al Cu/Al Cu/Al Coil Type(Tube Dia.) 3/8" RTPF 3/8" RTPF 3/8" RTPF 3/8" RTPF Rows/FPI 4/15 4/15 4/15 3/15 Total face area(ft2) 11.1 11.1 11.1 17.5 Condensate drain conn.size 3/4" 3/4" 3/4" 3/4" HUMIDI-MIZER®COIL Material Cu/Al — Cu/Al Cu/Al Coil Type(Tube Dia.) 3/8" RTPF — 3/8" RTPF 3/8" RTPF Rows/FPI 2/17 — 2/17 2/17 Total face area(ft2) 8.4 — 8.4 13.8 EVAPORATOR FAN AND MOTOR —_ Motor Qty./Driver Type 1 /Belt 1/Belt 1/Belt 1 /Belt Max BHP 2.4 2.4 2.9* 2.9* Standard RPM range 591-838 591-838 652-843 507-676 Static Motor frame size 56 56 56 56 Fan Qty./Type 1/Centrifugal 1/Centrifugal 1/Centrifugal 1/Centrifugal Fan Diameter(in.) 15 x 15 15 x 15 15 x 15 18 x 18 Motor Qty./Driver Type 1 /Belt 1/Belt 1/Belt 1 /Belt Max BHP 3.7 3.7 3.7 3.7 Medium RPM range 838-1084 838-1084 838-1084 627-851 Static Motor frame size 56 56 56 56 Fan Qty./Type 1/Centrifugal 1/Centrifugal 1/Centrifugal 1/Centrifugal Fan Diameter(in.) 15 x 15 15 x 15 15 x 15 18 x 18 Motor Qty./Driver Type 1 /Belt 1/Belt 1 /Belt 1 /Belt Max BHP 4.7 4.7 4.7 6.5/6.9/7.0/8.31 High RPM range 1022-1240 1022-1240 1022-1240 776-955 Static Motor frame size 14 14 14 S184T Fan Qty./Type 1 /Centrifugal 1 /Centrifugal 1/Centrifugal 1/Centrifugal Fan Diameter(in.) 15 x 15 15 x 15 15 x 15 18 x 18 CONDENSER COIL Material(Tube/Fin) Cu/Al Cu/Al Cu/Al Cu/Al Coil Type 3/8" RTPF 3/8" RTPF 3/8" RTPF 3/8" RTPF Rows/FPI 2/17 2/17 3/17 2/17 Total Face Area(ft2) 25.1 25.1 25.1 2@23.1 ALTERNATE(MCHX)CONDENSER COIL Material(Tube/Fin) Al/Al — Al/Al — Coil Type Novation® — Novation® — Rows/FPI 1 /20 — 1/20 Total Face Area(ft2) 25.1 — 25.1 COND.FAN!MOTOR Qty/Motor Drive Type 2/Direct 2/Direct 1/Direct 3/Direct Motor HP/RPM 1/4/1100 1/4/1100 1/4/1175 1/4/1100 Fan diameter(in.) 22 22 30 22 FILTERS —_ RA Filter#/Size(in.) 4/20x20x2 4/20x20x2 4/20x20x2 6/18x24x2 2/24 x 27 x 1 (vert.) OA inlet screen#/Size(in.) 1 /20x 24 x 1 1 /20 x 24 x 1 1 /20 x 24 x1 1 /30 x 39 x 1 (horiz.) LEGEND Voltage BHP — Not applicable 208 6.5 575V motor utilizes 3.7 BHP. 230 6.9 t On size 16 units,Max BHP for the Hight Static motor varies with 460 7.0 the motor's voltage;see the Voltage/BHP table to the right. 575 8.3 NOTE:Humidi-MiZer®is not available with Novation®condenser coil models, only Round Tube/Plate Fin(RTPF)up to size 16. 24 818 Physical data q'arriet'D { United Uehaele;lee PHYSICAL DATA (HEATING) - 12.5-15 TONS • 48TC 48TC**14 48TC**16 GAS CONNECTION #of Gas Valves 1 1 Natural Gas supply line press. (in.w.g.)/(PSIG) 4-13/0.18-0.47 5-13/0.18-0.47 LP supply line press. (in.w.g.)/(PSIG) 11-13/0.040-0.047 11-13/0.040-0.047 HEAT ANTICIPATOR SETTING(AMPS) 1st stage 0.14 0.14 2nd stage 0.14 0.14 NATURAL GAS HEAT #of Stages/#of Burners(Total) 2/4 2/6 LOW Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise 25-65 20-55 #of Stages/#of Burners(Total) 2/5 2/8 MEDIUM Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise 30-65 25-60 #of Stages/#of Burners(Total) 2/5 2/10 HIGH Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise 35-70 35-65 LIQUID PROPANE HEAT #of Stages/#of Burners(Total) 2/4 2/6 LOW Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise 25-65 20-55 #of Stages/#of Burners(Total) 2/5 2/8 MEDIUM Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise 35-65 25-60 #of Stages/#of Burners(Total) 2/5 2/10 HIGH Connection Size 3/4" NPT 3/4" NPT Rollout switch opens/closes 195/115 225/145 Temperature Rise Options and accessories (cont) (Carrie) untrained people could have access to the unit's exterior proper connection and seal when routing wire and piping (07-14 sizes only). through the rooftop's basepan and curb. These couplings Alternate motors and drives eliminate roof penetration and should be considered for gas lines, main power lines, as well as control power. Some applications need larger horsepower motors, some need more airflow, and some need both. Regardless of the Condensate Overflow Switch case, your Carrier expert has a factory-installed combina- Includes electronic controller and sensor. Compressor(s) tion to meet your application. A wide selection of motors turn off if the drain trap becomes plugged but the indoor _ and pulleys (drives) are available, factory-installed, to han- fan motor remains running. dle nearly any application. Supply duct cover Thru-the-base connections This supply duct cover is required when field converting Thru-the-base connections, available as either an acces- the factory standard vertical duct supply to the horizontal sory or as a factory option, are necessary to ensure duct supply configuration. One required per unit (16 size only). OPTIONS AND ACCESSORIES—WEIGHT ADDERS MAX WEIGHT ADDER BASE UNIT WITH OPTIONS AND 48TC**07 48TC**08 48TC**09 48TC**12 48TC**14 48TC**16 ACCESSORIES(WEIGHT ADDERS) lb kg lb kg lb kg lb kg lb kg lb kg Humidi-MiZer®System1,2 55 25 80 36 80 36 80 36 80 36 90 41 Power Exhaust,Vertical 50 23 75 34 75 34 75 34 75 34 85 39 Power Exhaust,Horizontal 30 14 30 14 30 14 30 14 30 14 75 34 EconoMi$er®(IV,X,or 2) 50 23 74 34 74 34 74 34 74 34 103 47 Cu/Cu Condenser Coil3 28 13 28 13 30 14 34 15 34 15 34 15 Cu/Cu Condenser and Evaporator Coils3 53 24 58 26 64 29 64 29 64 29 64 29 Medium Gas Heat 9 4 15 7 15 7 18 8 18 8 28 13 High Gas Heat 17 8 29 13 29 13 35 16 35 16 50 23 Flue Discharge Deflector 7 3 7 3 7 3 7 3 7 3 7 3 _ Roof Curb 14-in.(356 mm) 115 52 143 65 143 65 143 65 143 65 180 82 Roof Curb 24-in.(610 mm) 197 90 245 111 245 111 245 111 245 111 255 116 Louvered Hail Guard 16 7 34 15 34 15 34 15 34 15 45 20 CO2 sensor 5 2 5 2 5 2 5 2 5 2 5 2 Return Smoke Detector 5 2 5 2 5 2 5 2 5 2 5 2 Supply Smoke Detector 5 2 5 2 5 2 5 2 5= 2 5 2 Fan/Filter Status Switch 2 1 2 1 2 1 2 1 2 1 2 1 Non-Fused Disconnect 15 7 15 7 15 7 15 7 15 7 15 7 Powered Convenience Outlet 35 16 35 16 35 16 35 16 35 16 35 16 Non-Powered Convenience Outlet 5 2 5 2 5 2 5 2 5 2 5 2 Enthalpy Sensor 2 1 y 2 1 2 1 2 1 2 1 2 1 Differential Enthalpy Sensor 3 1 3 1 3 1 3 1 3 1 3 1 Two Position Motorized Damper 39 18 58 26 58 26 58 26 58 26 65 29 Manual Outdoor Air Damper 12 2 18 8 18 8 18 8 18 8 25 11 Motormaster®Controller 35 16 35 16 35 16 35 16 40 18 40 18 Medium Static Motor/Drive 5 2 6 3 6 3 6 3 10 5 10 5 High Static Motor/Drive 11 5 12 5 16 7 16 7 20 9 20 9 SAVTM 2-Speed Indoor Fan Motor System 20 9 20 9 20 9 20 9 20 9 20 9 1 For Humidi-MiZer©System add Motormaster Controller. 2 Humidi-MiZer system is not available for 48TC*M08/09/12 units. 3 Where available. 30 • • NOTES: UNITED P.D.001 4806 THIS DOCUMENT IS IDE PROPERIT 0!CARRIER CORPORAIIOX SUBMISSION 0!MST DAMNS OR OOCUX[RS 1. DIMENSIONS ARE IN INCHES DIMENSIONS TECHNOLOGIES SYRACUS[.XT ANO IS DELIVERER UPON IM[[(PRESS CONDITION IXAi IN[ DOFf"'emir PARI PEPfORMAXC[OR IN I 1 ARE IN MILLIMETERS. UNIT OUTDOOR COIL TYPE H CARRIER Tool CORIOIASIOXT NOT BENRCOlLOVER OR USED XITHOOI CARRIER ACCEryirrr OT RT PORCI. 2.& CENTER OF GRAVITY 48TC-DTA MCHX 11 3/8 1299] CONNECTION SIZES 3. 100C-014 RTPF DIRECTION OF AIR(LOW 15 7/8 [103] 10-3/8 11026] A 1 3/8' [35]DIA FIELD POSER SUPPLY HOLE RTPF -ROUND TUBE, PLATE FIN(COPPER/ALUM) B 2 1/2' [641 DIA POWER SUPPLY KNOCKOUT MCHX-NOVATION(ALUM/ALUM) , C 1 3/1' 151]DIA GAUGE ACCESS PLUG ECONOMIZER HOOD 20-314 D 7/8. 122]DIA FIELD CONTROL WIRING HOLE (OPTIONAL) 5261 E 3/4•-14 NPT CONDENSATE DRAIN F 3/4'-1/NPT GAS CONNECTION R A-/ '. + T • G 2' 1511 DIA POWER SUPPLY KNOCK-OUT • FILTER ACCESS PANEL /// _ C • 1 7-. (DISPOSABLE FILTERS) 36-3/8 12-5/8 _\ 1925] THRU-THE-BASE CHART ""I / 0211 THESE HOLES REOUTAED FOR USE CONDENSER �/ _T-,3,t \\ RETURN AIR - N RETURN CRBTMPWRDOtA01,004A01 v R COIL I �� <;py 1\ I �IIIIIf��I�'����I��III��. �n111��II��IIIIII�I1lIl) AIR 4 �_ CONDUIT SI WIRE ACO'D HOLE ACCESSINDOOR COIL PANEL - ��� CONDUIT SIZE USE SIZES(MAX.) I� • \\\ 40-3/8 W 1/2' .ACC. 7/8'122.2] i %,,,,....---------�j 110271 % 1/2' 24V 7/8'122.21 z_,:� 28-3/4 1 1 1/4' (002,004) POWER 1 3//'114.4] iw 17311 37-5/8 O v "(:=!--2:1' -� I - • Y Sa]RLY 19551 y Z. (004)311•FPT GAS 1 Sl8'111.3] 300 . : 1' 'i00 18 16 # ( # .,�Z SUPPLY FOR'THRU-THE-BASEPAN'FACTORY OPTION, 14691[4121 14 it D SEE J AIR FITTINGS FOR ONLY%, Y, d 2 ARE PROVIDED 1355112791 THRU-THE-BASE - -_t BACK J i 1 1 Li, ........SMAFJ.... 4-. ..O? --- - .'ye. + (002)PROVIDES d/FI TTINGARO CURBFv 29-5/8IT- --6-1/4 1151] (159] 11001 — 14 E ALT. 1356] 1831 D. H B CONDENSATE _--3-1/4 2.1/8 DRAIN OPENING [131 /� I118IN BABE PAN 25-1/2 16461 4 13-118 6, ----------- - ELECTRICAL • --- OCA ONCT ,, —'��, CAyy -- -- !loyi: CONTROL BO% 7 X..1�� ACCESS PANELE OlD. 1,,,,ICONDENSATE li FILTER DRAIN• COXDCNSER j OPTIONAL INDOOR BLOWER 28-3/8N COIL FACTORYACCESS 1720]49-3/8 FLUE R13G2531 INSTALLED HOOU� SUPPLY AIR 36.3/8 ��_OPTIO [913] DCONNECT1925] 6�_11 FACT, I RETUR00INSTALLF, L OUT ) �I AIA 26CONVENIE 1HANDLE C HANDLE 13-7/8 �� , (619]OUTSIDE n 11 6.5/8 �. ♦ • 5-3/1 I - I1 4011, 6 B�l�I�ag� 11681 7160 �-7 r-7 : : OO,C [1461 4 2.5/8 -8-3/8 3-3/4 59-1/t [67) 6-3/8 7 5-3/4 1951 11510] TIP 37 [2141 11611 11771 1116] CURB 910] LEFT WIDTH 08-1/8 37-7/8 I 121381 19631 42 BAROMETRIC FRONT Il Ob6] RELIEF I Flow RETURN AIR RIGHT SHEET DAZE SOPERCEDES 48TC-14 SINGLE ZONE ELECTRICAL AEA 1 OF 2 10-04-10 08-30-10 COOLING WITH GAS HEAT 48TM501441 G W VIII ` U 3 CD M 0 UNITED P.O 605 ISIS IRIS 0010011 IS 1X5 000/001/01 CARRIER CWPORRi10A SMMISSIOA Of IX[S[011/1163 OA q(�I[115 TECHNOLOGIES SYRACUSE.1V ARD IS DELIVERED UPRI TRE EXPRESS 101011101 IXA1 THE DOTS 10i C05IIIUlE PRRi PLAfObAI.[OR 10/10113 BILI AOi B[DIS1lO3ED OR DOER 0111001 CARRIER ACC[P151L[OE 10115501. OUTDOOR STD. UNIT CORNER CORNER CORNER CORNER C G CARRIER Tun (gI10R5Tldl'S MIilF1 COYf[Ml. R�6. UNIT COIL WEIGHT... WEIGHT(A) WEIGHT (B) WEIGHT(C) WEIGHT(B) TYPE LBS. RG. LBS. RG. LBS. KG. IBS. NG. LBS. R6. R 1 1 0 48TC-DTI ACHE 1116 506 297 135 157 71 229 104 134 197 19 1/2 17491 3/1/1 ISMO] 20 1/4 15141 FOR TANDARD UNIT RDT NIT WAEIGD HT IS WITH ISSWITHSLOWE GAS HW GAS EATNANDRD WITHOUT DATA NGG. 48TC-DTI RTPF 1167 530 349 159 167 76 211 96 440 200 31 3/8 17911 34 3/4 18831 21 7/8(5561 RIPE -ROUND TUBE,PLATE FIN(COPPER/ALUM OCHE-MICROCHANNEL (ALUM/ALUM) CORNER A ^\ CORNER B CI • z O I(0 01% ,III,�ICP • CORNER D LJ CORNER C TOP C z Z a Nrri c -I n 0 1 4 IF.; O z Irt. o ' o FRONT SHEET DATE SUPERSEDES 48TC-14 SINGLE ZONE ELECTRICAL /0/2 10-04-10 08-30-10 COOLING WITH GAS HEAT 48TM501441 G sz %III Carrie UNIT DIMENSIONAL DRAWING-UNIT SIZE 48TC 14-SERVICE CLEARANCE '--,, N',. et6i,(,_11.20)1 - A I:) 'V 41111 \./ 11 BA LOC DIMENSION CONDITION 48-in.(1219 mm) •Unit disconnect is mounted on panel A 18-in.(457 mm) •No disconnect,convenience outlet option - 18-in.(457 mm) •Recommended service clearance 12-in.(305 mm) •Minimum clearance 42-in.(1067 mm) •Surface behind servicer is grounded(e.g.,metal,masonry wall) B 36-in.(914 mm) •Surface behind servicer is electrically non-conductive(e.g.,wood,fiberglass) Special _ •Check for sources of flue products within 10-ft of unit fresh air intake hood C 36-in.(914 mm) •Side condensate drain is used 18-in.(457 mm) •Minimum clearance 48-in.(1219 mm) •No flue discharge accessory installed,surface is combustible material D 42-in.(1067 mm) •Surface behind servicer is grounded(e.g.,metal,masonry wall,another unit) 36-in.(914 mm) •Surface behind servicer is electrically non-conductive(e.g.,wood,fiberglass) Special •Check for adjacent units or building fresh air intakes within 10-ft of this unit's flue outlet NOTE: Unit not designed to have overhead obstruction. Contact Application Engineering for guidance on any application planning overhead obstruction or vertical clearances. 41 TRANS® 1 t ti _ ... . 0 Packaged Gas/Electric-6.y.\ Rooftop ,* .,...,.....::.:,,,,.............,,.;,„... ,g_,,,,, , Units VoyagerTM 121/2 -25Tons - 60 Hz : t ' $' .: December 2003 RTPRC001-EN TRANS® Model Number Description Packaged Gas/Electric UnitTypical Model Nomenclature Y C D 1 5 0 C 3 L 0 A A 1 2 3 4 5 6 7 8 9 10 11 12 Digits 1,2-Product Type Digit 8-Electrical Characteristics YC=Packaged Gas/Electric 3 =208-230/60/3 4 =460/60/3 YF=With Factory Installed Options W=575/60/3 K =380/60/3 Digit 3-Airflow Configuration Digit 9-Heating Capacity D = Downflow H=Horizontal L =Low Heat M =Medium Heat Digits 4,5, 6-Nominal Gross Cooling H =High Heat Capacity IMBh/ Digit 10- Factory-Installed Options 150 = 12'%Ton Standard Efficiency 151 = 12'% Ton High Efficiency 0 =Packed Stock, No Options 180 = 15 Ton Standard Efficiency A =Downflow Economizer 181 = 15 Ton High Efficiency B =Oversized Motor 210 = 17%Ton Standard Efficiency C =Downflow Economizer and Oversized 211 = 17'% Ton High Efficiency Motor 240 = 20 Ton Standard Efficiency F =Trane Communications Interface (TCI) 241 = 20 Ton High Efficiency G =Downflow Economizer and TCI 300 = 25 Ton Standard Efficiency H =TXV/Face-Split Evaporator 301 = 25 Ton High Efficiency J =Oversized Motor and TXV/Face-Split Evaporator Digit 7-Major Development Sequence K =Downflow Economizer, Oversized Motor, and TXV/Face-Split Evaporator L =Downflow Economizer and TXV/Face- Split Evaporator Digit 11-Minor Design Sequence Digit 12-Service Digit RT-PRC001-EN 11 0 TRANE® . General DataStandard Et : i Table GD-1 - General Data 121/2Ton Downflow and Horizontal Units 15Ton Downflow and Horizontal Units YC*15003,D4,DWL,DK YC*150D3,D4,DWH,DK YC*18063,B4,BWL,BK YC*18063,B4,BWH,BK Coo&g Performance, Gross Cooling Capacity 150,000 182,000 EER2(Downflow,Horizontal) 9.6 9.7 Nominal CFM/ARI Rated CFM 5,000/4,400 6,000/5,300 ARI Net Cooling Capacity 142,000 174,000 Integrated Part Load Value3 10.3 10.0 System Power(KW) 14.79 17.94 Heating Performance' Heating Models Low High Low High Heating Input(Btuh) 150,000 250,000 250,000 350,000 1st Stage 100,000 175,000 175,000 250,000 Heating Output(Btuh) 122,000 203,000 203,000 284,000 1st Stage 81,000 142,000 142,000 203,000 AFUE(%)6 (Downflow/Horizontal) 81.0 80.7/79.9 80.7/79.9 80.1/79.1 Steady State Efficiency(%) 81.0 81.0 81.0 81.0 No.Burners 1 1 No.Stages 2 2 Gas Supply Pressure(in.w.c) Natural or LP(minimum/maximum) 2.5/14.0 2.5/14.0 Gas Connection Pipe Size(in.) 1/2 1/2 3/4 Compressor No./Type 2/Climatuff° Scroll 2/Trane 3-D5 Scroll/Climatuff Scroll - Sound Rating(BELS)6 9.2 9.2 Outdoor Coil-Type Hi-Performance Hi-Performance Tube Size(in.)OD .375 .375 Face Area(sq ft) 24.18 27.12 Rows/FPI 2/16 3/16 Indoor Coil-Type Hi-Performance Hi-Performance Tube Size(in.) .375 .375 Face Area(sq ft) 17.5 17.50 Rows/FPI 2/15 2/15 Refrigerant Control _ Short Orifice Short Orifice Drain Connection No./Size(in.) 1/1.00NPT 1/1..00NPT Outdoor Fan-Type Propeller Propeller No.Used/Diameter(in) 2/26 2/26 Drive Type/No.Speeds Direct/1 Direct/1 CFM 10,600 10,200 No.Motors/HP 2/.5 2/.50 Motor RPM 1,100 1,100 Indoor Fan-Type FC Centrifugal FC Centrifugal No.Used,Diameter(in.) 1/15 X 15 1/15 X 15 Drive Type/No.Speeds Belt/1 Belt/1 No.Motors 1 1 Motor HP(Standard/Oversized)9 3.0/5.0 3.0/5.0 Motor RPM(Standard/Oversizedl9 1740/3450 1740/3450 Motor Frame Size(Standard/Oversized)9 145T/145T 145T/145T Filters-Type Furnished Throwaway8 Throwaway8 (No.)Size Recommended Downflow (2)20X20X2,(4)20X25X2 (2)20X 20X 2,14)20X 25 X 2 Horizontal (2)20X 20X 2(4)20X 25X 2 (2)20X 20X 2,(4)20X 25 X 2 Refrigerant Charge(Lbs of R-22)7 9.3/9.4/Circuit 17.5/9.5/Circuit NOTES 1. Cooling Performance is rated at 95°F ambient,80°F entering dry bulb,67°F entering wet bulb.Gross capacity does not include the effect of fan motor heat.ARI capacity is net and includes the effect of fan motor heat.Units are suitable for operation to±20%of nominal cfm.Certified in accordance with the unitary large equipment certification program,which is - based on ARI Standard 340/360-93. 2. EER is rated at ARI conditions and in accordance with ARI Standard 210/240 or 360. - 3. Integrated Part Load Value is rated in accordance with ARI Standard 210/240 or 360.Units are rated at 80°F ambient,80°F entering dry bulb,and 67°F entering wet bulb at ARI rated cfm. 4. Heating Performance limit settings and rating data were established and approved under laboratory test conditions using American National Standards Institute standards.Ratings shown are for elevations up to 2000 feet.For elevations above 2000 feet,ratings should be reduced at the rate of 4%for each 1000 feet above sea level. 5. AFUE is rated in accordance with DOE test procedures. 6. Sound Rating shown is tested in accordance with ARI Standard 270 or 370. 7. Refrigerant charge is an approximate value.For a more precise value,see unit nameplate and service instructions. 8. An optional 2 inch pleated filter is also available. 9. For 380V/60Hz units,the oversized mtoor is used as the standard motor.Refer to oversized motor data. *Indicates both downflowand horizontal units. 12 RT-PRC001-EN 0 TRANS® • Dimensional 121 T High Efficiency Dataif 2 T Standard fcie iiimiiiimmillmillit All dimensions are in inches. 71 5/16" 107 5/16" 13/16" FILTER - ACCESS DOOR HORIZONTAL / ONLY \\`` �' 50 2/16" DOWNFLOW 1".....a� CONDENSATE DRAIN CONNECTION - ' 1.00 NPT 28 5/16"I p 414111 J 5 15/16" ` 6 1/2"NPT GAS INLET 2 11/16" 7/8"DIA. HOLE (YC•180B-H - 3/4 NPT) 8 3/8" (UNIT CONTROL WIRES) (YC•210C-H-3/4 NPT) 106 11/16" 16" SERVICE GAUGE 70 13/16" PORT ACCESS 2"DIA. HOLE (UNIT POWER WIRES) \1" 1 1/2"PERIMETER '---_______76/ NOTE: CURB FLANGE �/� 7/8' 1• 101 7/8' " Duct flanges mount 7-7116" down r7ns sse� s3' '� 171/8 1 inside the curb on the 1-112"curb / `!� 28 1/2" flanges. See recommended duct / Jit' �� �` ddd / dimensions on the next page. � dimensions is intended for �' � ,..-k ..%111pr. P downflow use only. 111%Ti�� ��, 141/16• 2' _ ` `"III ,444.44:` -7-- rlrr44:1414 sT 102 1/4' Downflow Unit Clearance DUWNFLOW - 36 f---------- CLEARANCE 68" � / UNIT OUTLINE / CLEARANCE FROM TOP OF UNIT 72" R❑❑F t OPENING-Th 62 1/2" / 73 1/2" CLEARANCE 48" CLEARANCE 60" \ 48 RT-PRC001-EN • • 0 TRANE Dimensional 1711--7-3rt High Efficiency Data a, - - andard Efficiency All dimensions are in inches. 1" Downflow Duct Connections—Field Fabricated 17 7/8" 7/16" ‘. 26 5/16" 1" 411 , :17%004 I PERIMETER 14 1/16" 40#/* CURB FLANGE 1 ' 7 7/16" \O 4-e" i 0'. 1 b* A i NOTE: 4401 • „‘\t Duct flanges mount 7-7/16” 4)9Y Z • 47 C::::::: 48 Horizontal Unit Supply/Return 140" CLEARANCE 60 and Unit Clearance 40 ,.--A-----..„ -,--=-7----=Fr. ) •:.--M. 1-1-n ''''---:------- --- FILTER ACCESS DOOR sz—a 4 HORIZONTAL UNITS ONLY 4\1 RETURN G' HORIZONTAL 1111.11*. 261/2 41 422 CONDENSATE DRAIN • CONNECTION 41 1.0 NPT 249/6 • CLEARANCE 18 --4.. . 1916 ....... CLEARANCE 38 -w, 2 RT-PRC001 EN 49 • TRAIN® Dimensional Data 'I - 25Tons) _ Downflow j- j Condensate Location 1 ,____. ,, n b — I K "K„ (?IIL f — — RIoal I I E I eate >>�� I SI T I G Location k �,,:.:-,�� u �� I P I H I N I I L I I I Y F „E„ / l'Condensate --at. A B v C 1a Location D E v Table DD-3—Standard Efficiency Units Condensate Drain Location Condensate Tons Downflow Only Drain Size Downflow Horizontal A B C D F G H E J E K 12'/,15,17% 26-7/16 22-1/2 18-11/16 4-1/4 4-1/4 62-7/16 54-11/16 1 NPT — 25-58 — 5-38 20,25 26-7/16 28-3/4 19-15/16 4-1/4 4-1/4 76-5/16 68-11/16 1 NPT — 26-3/4 — 5-3/8 Table DD4— High Efficiency Units Condensate Drain Location Condensate Tons Downflow Only Drain Size Downflow Horizontal A B C D F G H E J E K 12'% 26-7/16 22-1/2 18-11/16 4-1/4 4-1/4 62-7/16 54-11/16 1 NPT — 25-5/8 — 6 - 15-25 26-7/16 28-3/4 19-15/16 4-1/4 4-1/4 76-5/16 68-11/16 1 NPT — 26-3/4 — 5-3/8 RT-PRC001-EN 55 0 TRA NE® Weights • r x �, PON,. . Table W-1—Accessory Net Weights(Lbs)1'2 Oversize LPG All High" Low' Unit Economizer Outside Air Damper Roofs Motor Conversion Zone Powers Static Static Model No. Net Motorized Manual Curb Adder Kit Sensors Exhaust Drive Drive YCD 180B,210C YCD150D,151C 65 60 32 205 5 5 1 95 2 2 YCD240B YCD181,211,241C 80 75 32 235 5 5 1 95 2 — YCD300B,301C 80 75 32 235 — 5 1 95 — 2 YCH1806,210C YCH150D,151C 50 60 32 N/A 5 5 1 N/A 2 — YCH240B YCH181,211,241C 65 75 32 N/A 5 5 1 N/A 2 — YCH300B,301C 65 75 32 N/A — 5 1 N/A — 2 NOTES: 1. Net weight should be added to unit weight when ordering factory installed accessories. 2. YC*150-300 factory installed options for economizers,multiply net capacity x.99,EER x.97. For oversize motors,multiply net capacity x.98,FFR x.93.This is provided in compliance with ARI certification program. 3. Downflow only. 4. Not available on all models(See fan performance tables for specific models). Table W-2—Factory Installed Options(FlOPS)Net Weights(Lbs).z 3 Accessory Model Accessory Number Weight FIYHEMT001,002 15 High Efficiency Motors FIYHEMT003-005 49 FIYHEMT006-008 36 Hinged Doors FIYHNGE001,002 10 FIYHNGE003-009 27 Powered Convenience Outlet FIYCOP0101-206 38 FIYTBUE101-111 16 Through the Base Electrical FIYTBUE201-216 23 FIYUCB4015-4150 5 Unit Mounted Circuit Breaker FIYUCB3175-3250 10 FIYUDC4150,6100 5 Unit Mounted Disconnect FIYUDC3250 10 NOTES 1. Weights for FIOP accessories not listed are>5 lbs. 2. Net weight should be added to unit weight when ordering factory installed accessories. 3. See Table W-1 for standard factory installed economizer and oversized motors. • 56 RT-PRC001-EN 0 TRADE® Weights ,,,, F.$ ': Table W-3—Maximum Unit And Corner Weights(Lbs)And Center Of Gravity Dimensions(In.) Unit Maximum Weights(Lbs)2 Corner Weights(Lbs)1 Center of Gravity(In.) Tons Model No. Shipping Net A B C D Length Width 121/2 YC*150D/YC*151C 1826/1915 1458/1547 495/523 373/383 254/271 336/370 46/45 29/30 15 YC*1808/YC*181C 2033/2464 1665/2005 600/686 395/504 266/345 404/470 43/52 29/35 17% YC*2100/YC*211C 2189/2547 1821/2088 618/701 463/538 317/369 424/480 46/53 29/35 20 YC*2403/YC*241C 2547/2645 2088/2186 738/751 526/568 343/373 481/494 51/53 34/34 25 YC*3006/YC*301C 2541/2650 2082/2191 721/755 552/569 351/373 458/495 53/53 33/34 NOTE 1. Corner weights are given for information only.121/2-25 ton must be supported continuously by a curb or equivalent frame support. 2. Weights are approximate.Horizontal and Downflow unit and corner weights may vary slightly. CENTER OF GRAVITY LENGTH AB CENTER OF GRAVITY 0 0 WIDTH i D" C CENTER OF GRAVITY *Indicates both downflow and horizontal units. RT-PRC001-EN 57